Honda2007–2012

CR-V 2.0: Common faults & known problems

Common faults & known problems

14 known faults documented in workshop bulletins. Of these, three concern the engine and fuel system and three the brakes. Symptoms, causes, repair steps and part numbers are shown where supplied.

Technical specifications

Engine & fuel system

3 documented faults — symptoms, causes and workshop fixes.

Vibration through vehicle when engine idling or on light throttle. More pronounced in cold weather

Rear exhaust silencer mounting rubbers excessively compressed due to silencer hanger bracket incorrectly positioned.

Overview

Affects: All models.

Repair steps

Remove rear exhaust silencer.
Adjust rear exhaust silencer hanger brackets: Raise silencer hanger LH bracket by 2 - 3 mm Lower silencer hanger RH bracket by 2 - 3 mm.
Refit rear exhaust silencer.

Parts

Parts listed in the bulletin
Part	Part number	Qty
Nut	90115-659-003	2
Gasket (petrol)	18229-SNA-A01	1
Gasket (Diesel)	18229-S7S-003	1

Data: Motorwise Workshop. Bulletin 11.

Engine malfunction indicator lamp (MIL) illuminated. Trouble code stored: P2647

Affects All models with petrol engines.P2647Fit new part

Cause

Variable valve lift oil pressure valve stuck or sticking.

Repair

Fit new variable valve lift oil pressure valve.

Data: Motorwise Workshop. Bulletin 12.

Shudder from rear of vehicle when cornering

Affects All models with four wheel drive.

Cause

Incorrect specification rear differential oil used.

Repair

Renew rear differential oil. Ensure rear differential oil to manufacturer's specifications.

Data: Motorwise Workshop. Bulletin 14.

Brakes

3 documented faults — symptoms, causes and workshop fixes.

Trouble code stored: U0122

Poor earth connection for ABS control module. Fix: adjust and tighten.

Overview

Affects: CR-V, MY 2007.
Fault codes: U0122
Remedy: Adjust & tighten

Symptoms

Possible CAN data bus trouble codes stored.

Repair steps

Locate and check condition of earth point: Civic - behind front bumper. CR-V - under ABS control module.
If required: Clean/tighten earth point.
Check for trouble codes. Rectify faults as necessary.

Data: Motorwise Workshop. Bulletin 3.

Loss of braking efficiency

Affects All models.

Symptoms

Trouble codes stored: 43, 47.

Cause

Incorrect front brake system fluid pressure.

Repair

Check front ABS brake fluid pressure sensors for correct operation before replacing ABS hydraulic modulator.

Data: Motorwise Workshop. Bulletin 9.

Squeal from front brakes when applied in low ambient air temperatures

Overview

Affects: All models, →2009.
Remedy: Clean & lubricate
Parts: 2 parts

Cause

Vibration between front brake pads and discs.

Repair

Remove front brake pads. Thoroughly clean all mating surfaces.
Ensure brake pad anti-squeal shims are fitted. Refit front brake pads.

Parts2 parts

Parts listed in the bulletin
Part	Part number	Qty
Anti-rattle clip kit	45011-SWW-305	1
Anti-squeal shim kit	45226-SWW-G01	2

Data: Motorwise Workshop. Bulletin 10.

Suspension & drivetrain

1 documented fault — symptoms, causes and workshop fixes.

Creaking noise from rear suspension at low vehicle speed

Affects All models, →09/07.

Cause

Rear suspension springs chafing on rear shock absorbers.

Repair

Fit rear suspension spring rubber insulation cups.

Parts1 part

Parts listed in the bulletin
Part	Part number	Qty
Rubber insulation cup	52613-SWA-E00	2

Data: Motorwise Workshop. Bulletin 6.

Steering

1 documented fault — symptoms, causes and workshop fixes.

Steering wheel vibration at 50-75mph (80-120kph) after new tyres fitted

Affects All models.

Cause

New tyres incorrectly fitted.

Repair

Ensure heavy point of tyre is opposite tyre valve. Ensure wheels are balanced correctly.

Data: Motorwise Workshop. Bulletin 8.

Clutch & gearbox

3 documented faults — symptoms, causes and workshop fixes.

Squeaking/creaking noise when clutch pedal depressed or released

Affects All models.Clean & lubricate

Cause

Cruise control clutch pedal switch contaminated with dirt.

Repair

Clean and lubricate contact point between cruise control clutch pedal switch and clutch pedal.

Data: Motorwise Workshop. Bulletin 4.

Squeaking/creaking noise when clutch pedal depressed or released

Clutch master cylinder and clutch pedal misaligned. Fix: adjust and tighten.

Overview

Affects: All models.
Remedy: Adjust & tighten

Repair steps

Slacken clutch master cylinder retaining bolts.
Fully depress clutch pedal and hold down.
Tighten clutch master cylinder retaining bolts. Tightening torque: 22 Nm.
Release clutch pedal.

Data: Motorwise Workshop. Bulletin 5.

Battery discharged

Affects All models with air conditioning (AC).

Symptoms

Irregular operation of AC compressor clutch.

Cause

AC compressor clutch relay faulty. Note: This fault is only associated with relays made by Omron.

Repair

Replace AC compressor clutch relay.

Parts1 part

Parts listed in the bulletin
Part	Part number	Qty
AC compressor clutch relay	39794-SDA-A05	1

Data: Motorwise Workshop. Bulletin 13.

Air conditioning & heating

1 documented fault — symptoms, causes and workshop fixes.

Whistling noise from air conditioning (AC), when operating

Affects All models, 2007-08: VIN →SHSRE5***8U016571. VIN →SHSRE7***8U004030.Fit modified part

Cause

Resonance from expansion valve/pipe assembly.

Repair

Fit modified expansion valve/pipe assembly.

Parts2 parts

Parts listed in the bulletin
Part	Part number	Qty
Expansion valve/pipe assembly - RHD	06802-SWW-E00	1
Expansion valve/pipe assembly - LHD	06802-SWW-G00	1

Data: Motorwise Workshop. Bulletin 1.

Body & trim

1 documented fault — symptoms, causes and workshop fixes.

Rear folding seat base latch difficult to disengage

Affects All models, 2007-08.

Cause

Rear folding seat base catch misaligned.

Repair

Using a suitable tool, adjust rear folding seat base catch.

Data: Motorwise Workshop. Bulletin 7.

Wipers & visibility

1 documented fault — symptoms, causes and workshop fixes.

Creaking noise from windscreen wipers

Overview

Affects: All models, 2007-08: VIN →SHSRE5***8U010589. VIN →SHSRE6***8U009717.

Cause

Side panel and windscreen lower panel rubbing together.

Repair

Remove engine bay trim panels to gain access to right-hand bonnet hinge.
Increase the clearance between side panel and windscreen lower panel. Modify affected area using a hammer and a suitable tool (centre punch).

Data: Motorwise Workshop. Bulletin 2.

Glossary

Technical terms used in this guide.

VIN: Vehicle identification number — 17 characters, found at the base of the windscreen and on the V5C logbook
Nm: Newton-metres — the standard unit for how tightly a bolt is done up
ABS: Anti-lock braking system — stops the wheels locking under hard braking
Trouble Codes: Standardised fault codes stored by the engine control module, read with a diagnostic tool
AC: Air conditioning — the system that cools the cabin
LH: Left-hand — the left side of the vehicle as you sit in it
RH: Right-hand — the right side of the vehicle as you sit in it
CAN Data Bus: The car's internal network that lets control modules talk to each other
Control Module: A control unit for one of the vehicle's systems (engine, gearbox, brakes, body, and so on)
Expansion Valve: The air-conditioning valve that lets refrigerant drop in pressure so it can absorb heat
Relay: An electrically operated switch
Earth: An electrical ground connection back to the battery or body

Frequently asked questions

What are the common faults with the Honda CR-V 2.0?

This guide contains 14 workshop bulletins for the Honda CR-V 2.0. Of these, three concern the engine and fuel system and three the brakes. Symptoms, causes, repair steps and part numbers are shown where supplied.

Does every Honda CR-V 2.0 have these faults?

No. These are patterns documented across the model by workshops, not predictions for an individual vehicle. Where a fault applies only to certain vehicles or VIN ranges, that is listed with the fault.

Can I check for Honda CR-V 2.0 faults myself?

Many of them. The documented symptoms can be seen, heard or felt during a test drive.