Honda2007–2010

CR-V 2.2 i-CTDi: Common faults & known problems

Common faults & known problems

20 known faults documented in workshop bulletins. Of these, six concern the engine and fuel system and four the clutch and gearbox. Symptoms, causes, repair steps and part numbers are shown where supplied.

Technical specifications

Engine & fuel system

6 documented faults — symptoms, causes and workshop fixes.

Engine malfunction indicator lamp (MIL) illuminated

Overview

Affects
All models with N22A2 engine code, VIN →SHSRE6***8U038776.
Fault codes
P1248P2138
Remedy
Software update

Symptoms

No throttle response. Trouble codes stored in engine control module (ECM) fault memory: P1248, P2138.

Cause

Engine control module (ECM) software fault.

Repair

  1. Carry out electrical, mechanical and component tests (as applicable) to eliminate any other possible cause(s).
  2. If no fault(s) found: Re-program ECM with upgraded software.

Data: Motorwise Workshop. Bulletin 13.

Intermittent power loss

Overview

Affects
All models with N22A1/N22A2 engine codes: VIN: JHMBE5***6S000002-JHMBE5***6S216277. VIN: SHSRD9***5U000101-SHSRD9***5U26519. VIN: SHSRD9***6U100101-SHSRD9***6U127998.
Fault codes
P1401
Remedy
Fit modified part
Parts
1 part

Symptoms

Engine stalls. Hesitates when accelerating. Possible trouble code stored: P1401.

Cause

Engine control module (ECM) software fault.

Exhaust gas recirculation (EGR) valve sticking due to carbon build up.

Repair

  1. Carry out electrical, mechanical and component tests (as applicable) to eliminate any other possible cause(s).
  2. If no fault(s) found: Fit modified EGR valve. Re-program engine control module (ECM) with upgraded software.
Parts1 part
Parts listed in the bulletin
PartPart numberQty
Exhaust gas recirculation (EGR) valve kit06180-RMA-3051

Data: Motorwise Workshop. Bulletin 14.

Vibration through vehicle when engine idling or on light throttle. More pronounced in cold weather

Rear exhaust silencer mounting rubbers excessively compressed due to silencer hanger bracket incorrectly positioned.

Overview

Affects
All models.

Repair steps

  1. Remove rear exhaust silencer.
  2. Adjust rear exhaust silencer hanger brackets: Raise silencer hanger LH bracket by 2 - 3 mm Lower silencer hanger RH bracket by 2 - 3 mm.
  3. Refit rear exhaust silencer.

Parts

Parts listed in the bulletin
PartPart numberQty
Nut90115-659-0032
Gasket (petrol)18229-SNA-A011
Gasket (Diesel)18229-S7S-0031

Data: Motorwise Workshop. Bulletin 16.

Engine malfunction indicator lamp (MIL) illuminated. Trouble code stored: P0087

Overview

Affects
All models with Diesel engines.
Fault codes
P0087
Remedy
Software update

Symptoms

Engine runs in limp home mode.

Cause

Engine control module (ECM) software fault.

Repair

  1. Carry out electrical, mechanical and component tests (as applicable) to eliminate any other possible cause(s).
  2. If no fault(s) found: Re-program engine control module (ECM) with upgraded software.

Data: Motorwise Workshop. Bulletin 18.

Shudder from rear of vehicle when cornering

Affects All models with four wheel drive.

Cause

Incorrect specification rear differential oil used.

Repair

  1. Renew rear differential oil. Ensure rear differential oil to manufacturer's specifications.

Data: Motorwise Workshop. Bulletin 19.

Lack of power

Affects All models with 2.2 Diesel engine.P2199Clean & lubricate

Symptoms

Poor engine performance under load. Possible trouble code stored in engine control module (ECM) fault memory: P2199.

Cause

Reduced air flow to turbocharger (TC) intercooler caused by dirt build up.

Repair

  1. Check and clean turbocharger (TC) intercooler.

Data: Motorwise Workshop. Bulletin 20.

Brakes

3 documented faults — symptoms, causes and workshop fixes.

Trouble code stored: U0122

Poor earth connection for ABS control module. Fix: adjust and tighten.

Overview

Affects
CR-V, MY 2007.
Fault codes
U0122
Remedy
Adjust & tighten

Symptoms

Possible CAN data bus trouble codes stored.

Repair steps

  1. Locate and check condition of earth point: Civic - behind front bumper. CR-V - under ABS control module.
  2. If required: Clean/tighten earth point.
  3. Check for trouble codes. Rectify faults as necessary.

Data: Motorwise Workshop. Bulletin 3.

Loss of braking efficiency

Affects All models.

Symptoms

Trouble codes stored: 43, 47.

Cause

Incorrect front brake system fluid pressure.

Repair

  1. Check front ABS brake fluid pressure sensors for correct operation before replacing ABS hydraulic modulator.

Data: Motorwise Workshop. Bulletin 11.

Squeal from front brakes when applied in low ambient air temperatures

Overview

Affects
All models, →2009.
Remedy
Clean & lubricate
Parts
2 parts

Cause

Vibration between front brake pads and discs.

Repair

  1. Remove front brake pads. Thoroughly clean all mating surfaces.
  2. Ensure brake pad anti-squeal shims are fitted. Refit front brake pads.
Parts2 parts
Parts listed in the bulletin
PartPart numberQty
Anti-rattle clip kit45011-SWW-3051
Anti-squeal shim kit45226-SWW-G012

Data: Motorwise Workshop. Bulletin 12.

Suspension & drivetrain

1 documented fault — symptoms, causes and workshop fixes.

Creaking noise from rear suspension at low vehicle speed

Affects All models, →09/07.

Cause

Rear suspension springs chafing on rear shock absorbers.

Repair

  1. Fit rear suspension spring rubber insulation cups.
Parts1 part
Parts listed in the bulletin
PartPart numberQty
Rubber insulation cup52613-SWA-E002

Data: Motorwise Workshop. Bulletin 7.

Steering

1 documented fault — symptoms, causes and workshop fixes.

Steering wheel vibration at 50-75mph (80-120kph) after new tyres fitted

Affects All models.

Cause

New tyres incorrectly fitted.

Repair

  1. Ensure heavy point of tyre is opposite tyre valve. Ensure wheels are balanced correctly.

Data: Motorwise Workshop. Bulletin 10.

Clutch & gearbox

4 documented faults — symptoms, causes and workshop fixes.

Squeaking/creaking noise when clutch pedal depressed or released

Affects All models.Clean & lubricate

Cause

Cruise control clutch pedal switch contaminated with dirt.

Repair

  1. Clean and lubricate contact point between cruise control clutch pedal switch and clutch pedal.

Data: Motorwise Workshop. Bulletin 4.

Engine runs erratically

Affects All models.

Symptoms

Vibrations from engine/transmission.

Cause

Dual mass flywheel faulty.

Repair

  1. Check dual mass flywheel. Replace as necessary.

Data: Motorwise Workshop. Bulletin 5.

Squeaking/creaking noise when clutch pedal depressed or released

Clutch master cylinder and clutch pedal misaligned. Fix: adjust and tighten.

Overview

Affects
All models.
Remedy
Adjust & tighten

Repair steps

  1. Slacken clutch master cylinder retaining bolts.
  2. Fully depress clutch pedal and hold down.
  3. Tighten clutch master cylinder retaining bolts. Tightening torque: 22 Nm.
  4. Release clutch pedal.

Data: Motorwise Workshop. Bulletin 6.

Battery discharged

Affects All models with air conditioning (AC).

Symptoms

Irregular operation of AC compressor clutch.

Cause

AC compressor clutch relay faulty. Note: This fault is only associated with relays made by Omron.

Repair

  1. Replace AC compressor clutch relay.
Parts1 part
Parts listed in the bulletin
PartPart numberQty
AC compressor clutch relay39794-SDA-A051

Data: Motorwise Workshop. Bulletin 17.

Air conditioning & heating

3 documented faults — symptoms, causes and workshop fixes.

Whistling noise from air conditioning (AC), when operating

Affects All models, 2007-08: VIN →SHSRE5***8U016571. VIN →SHSRE7***8U004030.Fit modified part

Cause

Resonance from expansion valve/pipe assembly.

Repair

  1. Fit modified expansion valve/pipe assembly.
Parts2 parts
Parts listed in the bulletin
PartPart numberQty
Expansion valve/pipe assembly - RHD06802-SWW-E001
Expansion valve/pipe assembly - LHD06802-SWW-G001

Data: Motorwise Workshop. Bulletin 1.

Engine malfunction indicator lamp (MIL) illuminated

Affects All models with 2.2 Diesel engine, 2007-09.P2004Fit modified part

Symptoms

Possible trouble code stored: P2004.

Cause

Intake manifold air control actuator faulty.

Repair

  1. Fit modified intake manifold air control actuator.
Parts1 part
Parts listed in the bulletin
PartPart numberQty
Intake manifold air control actuator36190-R06-E011

Data: Motorwise Workshop. Bulletin 9.

Engine malfunction indicator lamp (MIL) illuminated

Affects All models with N22A1/N22A2 engine codes: VIN →JHMCN1***C******. VIN →JHMCN2***C******. VIN →SHHFN3***9U001000. VIN →SHHFK3***9U004240. VIN →SHSRE6***9U001830.P2004Fit new part

Symptoms

Trouble code stored in engine control module (ECM) fault memory: P2004.

Cause

Intermittent internal vacuum leak in intake manifold air control solenoid.

Repair

  1. Fit new intake manifold air control solenoid.
Parts1 part
Parts listed in the bulletin
PartPart numberQty
Intake manifold air control solenoid36190-RBD-E011

Data: Motorwise Workshop. Bulletin 15.

Body & trim

1 documented fault — symptoms, causes and workshop fixes.

Rear folding seat base latch difficult to disengage

Affects All models, 2007-08.

Cause

Rear folding seat base catch misaligned.

Repair

  1. Using a suitable tool, adjust rear folding seat base catch.

Data: Motorwise Workshop. Bulletin 8.

Wipers & visibility

1 documented fault — symptoms, causes and workshop fixes.

Creaking noise from windscreen wipers

Overview

Affects
All models, 2007-08: VIN →SHSRE5***8U010589. VIN →SHSRE6***8U009717.

Cause

Side panel and windscreen lower panel rubbing together.

Repair

  1. Remove engine bay trim panels to gain access to right-hand bonnet hinge.
  2. Increase the clearance between side panel and windscreen lower panel. Modify affected area using a hammer and a suitable tool (centre punch).

Data: Motorwise Workshop. Bulletin 2.

Glossary

Technical terms used in this guide.

ECM
Engine control module — the electronic unit that manages the engine
VIN
Vehicle identification number — 17 characters, found at the base of the windscreen and on the V5C logbook
Nm
Newton-metres — the standard unit for how tightly a bolt is done up
ABS
Anti-lock braking system — stops the wheels locking under hard braking
EGR
Exhaust gas recirculation — feeds some exhaust gas back into the intake to cut emissions
Trouble Codes
Standardised fault codes stored by the engine control module, read with a diagnostic tool
AC
Air conditioning — the system that cools the cabin
LH
Left-hand — the left side of the vehicle as you sit in it
RH
Right-hand — the right side of the vehicle as you sit in it
TC
Turbocharger — the exhaust-driven compressor that boosts engine power
Actuator
A motor or solenoid that moves a mechanical part on command
CAN Data Bus
The car's internal network that lets control modules talk to each other
Control Module
A control unit for one of the vehicle's systems (engine, gearbox, brakes, body, and so on)
EGR Valve
The valve that meters exhaust gas back into the intake
Expansion Valve
The air-conditioning valve that lets refrigerant drop in pressure so it can absorb heat
Fault Memory
The list of stored trouble codes in a control module
Intake Manifold
The housing that distributes air into the cylinders
Intercooler
A radiator that cools the air coming out of the turbocharger before it enters the engine
Limp Home
A protective mode that limits power so the vehicle can be driven to a workshop
Re-Program
Update the software on a control module using the manufacturer's diagnostic tool
Relay
An electrically operated switch
Solenoid
An electrically operated valve or actuator
Trouble Code
A standardised fault code stored by a control module, read with a diagnostic tool
Earth
An electrical ground connection back to the battery or body
Recirculation
Air-conditioning mode that recirculates cabin air instead of drawing in outside air

Frequently asked questions

What are the common faults with the Honda CR-V 2.2 i-CTDi?

This guide contains 20 workshop bulletins for the Honda CR-V 2.2 i-CTDi. Of these, six concern the engine and fuel system and four the clutch and gearbox. Symptoms, causes, repair steps and part numbers are shown where supplied.

Does every Honda CR-V 2.2 i-CTDi have these faults?

No. These are patterns documented across the model by workshops, not predictions for an individual vehicle. Where a fault applies only to certain vehicles or VIN ranges, that is listed with the fault.

Can I check for Honda CR-V 2.2 i-CTDi faults myself?

Many of them. The documented symptoms can be seen, heard or felt during a test drive.

Related guides

Glossary term

See in the glossary →