Toyota2009–2013

Corolla 1.4 D-4D MY 09-: Common faults & known problems

Common faults & known problems

5 known faults documented in workshop bulletins. Of these, two concern the engine and fuel system and two the steering. Symptoms, causes, repair steps and part numbers are shown where supplied.

Engine & fuel system

2 documented faults — symptoms, causes and workshop fixes.

Poor cold starting

Overview

Affects
All models with 1ND-TV engine code, →12/09.
Remedy
Software update

Symptoms

Erratic idle when started from cold.

Cause

Faulty fuel injectors.

Engine control module (ECM) software fault.

Repair steps

  1. Carry out electrical, mechanical and component tests (as applicable) to eliminate any other possible cause(s).
  2. If no fault(s) found: Re-program ECM with upgraded software.
  3. Inspect part number on fuel injectors. If part number 23670-33050, replace fuel injectors.

Parts

Parts listed in the bulletin
PartPart numberQty
Fuel injector23670-330514

Data: Motorwise Workshop. Bulletin 3.

Engine oil leak from cylinder head area

Affects All models with 1.4 Diesel engine.Fit modified part

Cause

Cylinder head cover gasket damaged during assembly.

Repair

  1. Fit modified cylinder head cover gasket.
Parts1 part
Parts listed in the bulletin
PartPart numberQty
Cylinder head cover gasket11213-330311

Data: Motorwise Workshop. Bulletin 4.

Steering

2 documented faults — symptoms, causes and workshop fixes.

Knocking noise from steering when steering wheel turned

Overview

Affects
All models, →2008.
Remedy
Fit modified part

Cause

Dry contact surfaces on the steering column lower shaft splined joint.

Repair

  1. To confirm cause: Mark alignment of steering column lower shaft to steering rack. Detach steering column lower shaft from steering rack. Slide steering column lower shaft in and out 10 times. Ensure alignment of reference marks. Refit steering column lower shaft. Road test vehicle.
  2. If noise is no longer present: Fit modified steering column lower shaft.

Data: Motorwise Workshop. Bulletin 1.

Increased engine noise in passenger compartment

Steering column sealing boot cracked/damaged. Fix: fit a new part.

Overview

Affects
All LHD models.
Remedy
Fit new part

Symptoms

Driver's footwell carpet wet after heavy rain. Steering operation not smooth when manoeuvring or parking.

Repair steps

  1. Remove steering column sealing boot and discard.
  2. Fit protective cover to new steering column sealing boot Secure protective cover with retaining strap, ensure a clearance of 0.5 - 1.5 mm.
  3. Fit new steering column sealing boot complete with protective cover.

Parts

Parts listed in the bulletin
PartPart numberQty
Protective cover45254-020201
Steering column sealing bootRefer to manufacturer1

Data: Motorwise Workshop. Bulletin 5.

Clutch & gearbox

1 documented fault — symptoms, causes and workshop fixes.

Rattling noise from clutch assembly with engine idling and clutch pedal fully released

Overview

Affects
All models with 1ND-TV engine code.
Remedy
Fit modified part
Parts
3 parts

Cause

Unsatisfactory design of clutch assembly.

Repair

  1. Fit modified clutch assembly.
  2. Renew concentric clutch slave cylinder.
Parts3 parts
Parts listed in the bulletin
PartPart numberQty
Clutch assembly - except ASM transmission31250-521311
Clutch assembly - ASM transmission31250-521511
Concentric clutch slave cylinderRefer to manufacturer1

Data: Motorwise Workshop. Bulletin 2.

Glossary

Technical terms used in this guide.

ECM
Engine control module — the electronic unit that manages the engine
LHD
Left-hand drive — steering wheel on the left
Control Module
A control unit for one of the vehicle's systems (engine, gearbox, brakes, body, and so on)
Re-Program
Update the software on a control module using the manufacturer's diagnostic tool

Frequently asked questions

What are the common faults with the Toyota Corolla 1.4 D-4D?

This guide contains five workshop bulletins for the Toyota Corolla 1.4 D-4D. Of these, two concern the engine and fuel system and two the steering. Symptoms, causes, repair steps and part numbers are shown where supplied.

Does every Toyota Corolla 1.4 D-4D have these faults?

No. These are patterns documented across the model by workshops, not predictions for an individual vehicle. Where a fault applies only to certain vehicles or VIN ranges, that is listed with the fault.

Can I check for Toyota Corolla 1.4 D-4D faults myself?

Many of them. The documented symptoms can be seen, heard or felt during a test drive.

Related guides

Glossary term

See in the glossary →