Model Reports
8 min readUpdated 11 Sep 2026
DVSA open data · 10,567 tests analysed
Volkswagen Transporter 2006: reliability & common MOT faults
4,792 first-attempt MOT failures were recorded on the 2006 Volkswagen Transporter in 2025. Figures are among first-attempt failed MOT tests, not among all tests.
Drive shafts — Joints (front) was the most common reason a 2006 Transporter failed its MOT — 13.5% of its failed first attempts.
First-attempt pass
54.7%
of 10,567 first tests (2025)
First tests
10,567
test year 2025
Failed first attempts
4,792
failed first-attempt tests
MOT pass rates
First-attempt and official-style rates among class 4 first tests of the year.
First-attempt pass
54.7%
of 10,567 first tests (2025)
Official-style pass
60.5%
incl. same-day PRS fixes
First tests
10,567
class 4 · first MOT of the year
Typical age 19.0 yrs · median mileage 164,270 mi
vs 2024:
+0.6 pp first-attempt
Note:
Class 4 cars · first MOT of the year per vehicle · P/PRS/F outcomes (2025 data).
PRS (fixed at the station the same day) counts as a fail in the first-attempt rate.
Raw outcomes for this cohort — not adjusted for age, mileage, or peer mix.
MOT doesn't test engine or gearbox internals.
Common faults
Failure patterns that show up more often on this registration year than on similar cars.
These MOT failure patterns show up more often on this registration year than on
similar cars of the same class, age, and mileage.
Shares below are measured across the 4,788 of
4,792 failed first attempts
(99.9%) that recorded an odometer reading in 2025 —
the subset the age-and-mileage comparison can be computed on.
Standout: Pins and bushes (front) — 3.1% of this year's failed first attempts
Recorded on 150 of those tests. It tops the table on elevation — about 5.8× more often than on similar cars of the same age and mileage. That is what makes it unusual for its class, which is a different question from what is most likely to fail; the buying checklist ranks by that. The full ranked list is in the table below.
Fault pattern
Location
Failures
vs similar cars
Share of fails
Confidence
Rear reflectors
Lamps, reflectors and electrical equipment > Rear reflectors
Any
96
×11
2.0%
Likely
Pins and bushes (front)
Suspension > Anti-roll bars > Pins and bushes
Front
150
×5.8
3.1%
Strong
Flexible brake hoses (front)
Brakes > Flexible brake hoses
Front
222
×3.1
4.6%
Likely
Diesel emissions test (pre-reg turbo rules before 01/07/2008)
Any
385
×3.0
8.0%
Likely
Only patterns that clear minimum sample and elevation thresholds are shown
(at least 20 failures and about
2.0× more often than similar cars).
Note: Rates and comparisons are among first-attempt failed tests, not all MOTs. Patterns come from MOT defect codes — not manufacturer service bulletins, recalls, or a diagnosis of any individual car. Failures and advisories are listed separately.
Advisories
Notes recorded at the test that appear more often than on similar cars.
Advisory notes recorded on failed first-attempt tests that appear more often than on similar cars.
Advisory pattern
Location
Notes
vs similar cars
Share
Confidence
Pipes and hoses (front)
Steering > Power steering > Pipes and hoses
Front
111
×5.5
2.3%
Elevated
Pins and bushes (front)
Suspension > Anti-roll bars > Pins and bushes
Front
160
×3.9
3.3%
Strong
Component mounting prescribed areas (front)
Suspension > Component mounting prescribed areas
Front
115
×3.1
2.4%
Elevated
Seat belts — Condition (front)
Seat belts and supplementary restraint systems > Seat belts > Condition
Front
224
×3.1
4.7%
Possible
Ball joint (front)
Suspension > Other suspension component > Ball joint
Front
28
×2.8
0.6%
Likely
Sub-frame (front)
Suspension > Sub-frames > Sub-frame
Front
248
×2.7
5.2%
Elevated
Suspension arm (rear)
Suspension > Suspension arms > Suspension arm
Rear
279
×2.5
5.8%
Elevated
Flexible brake hoses (front)
Brakes > Flexible brake hoses
Front
295
×2.1
6.2%
Likely
Note: Advisories are not a fail rate — they flag issues noted at the test, often before they become failures.
If you are buying one
What this year's MOT record means for the decision in front of you.
Nothing separates this year from the Transporters either side of it, so buy on the individual car. The checks below are the items that actually failed 2006 Transporters, commonest first.
What to check on a 2006 Transporter
The items that failed 2006 Transporters most
often, as a share of the year's failed first attempts. This is what goes
wrong, not what is unusual — the table further up the page covers that.
Drive shafts — Joints (front) — recorded on 13.5% of failed first attempts
Rbt (sp) — recorded on 12.6% of failed first attempts
Visibility — Washers — recorded on 9.4% of failed first attempts
Position lamp (front) — recorded on 9.1% of failed first attempts
Pins and bushes (front) — recorded on 8.6% of failed first attempts
Every figure here is a first-attempt MOT rate from DVSA open data for this
model line. MOTs do not test engine or gearbox internals, so this is a
pre-purchase checklist, not a full reliability score.
FAQs
Short answers about how to read this model-year guide.
Drive shafts — Joints (front) was the most common reason a 2006 Transporter failed its MOT — 13.5% of its failed first attempts. In 2025, 54.7% of 10,567 first MOTs on the 2006 Volkswagen Transporter passed first time (PRS — items fixed at the station the same day — counted as a fail). The official-style rate including PRS is 60.5%. Among 4,792 failed first-attempt MOT tests (test year 2025), Pins and bushes (front)…
Ranked by how often they were actually recorded, the items that failed 2006 Volkswagen Transporters most often at the first attempt were Drive shafts — Joints (front) (13.5%), Rbt (sp) (12.6%) and Visibility — Washers (9.4%) — each as a share of the year's failed first attempts. That is what goes wrong on the car. It is a different question from which patterns are unusual for the class, which the common-faults table…
Among failed first-attempt tests we highlight patterns that appear more often than on similar cars. Top example: Pins and bushes (front) (3.1% of those tests; 150 observed failures; about 5.8× more often than similar cars). These are statistical signals, not a diagnosis of any individual car.
Pins and bushes (front) shows up more often than on similar cars (3.1% of those tests; 150 observed failures; about 5.8× more often than similar cars). That does not prove a design fault — age, mileage, and how the car was used still matter. Treat it as a pre-purchase check point, not a manufacturer service bulletin.
Common MOT problem areas for the 2006 Volkswagen Transporter include Pins and bushes (front), Rear reflectors, Flexible brake hoses (front). These patterns show up more often than on similar cars after we filter out sparse noise — not a full list of every possible fault on an individual car.
Advisories flag issues noted at the test and are not a fail rate. We show advisory patterns that appear more often than on similar cars among failed first-attempt tests, separate from common failure rows. Use them as early-warning checks, not as a pass/fail score.
This page highlights MOT failure patterns for the 2006 Volkswagen Transporter (registration year) using UK DVSA open data for the selected test year. Patterns are compared with cars of a similar age and mileage. It is a buyer checklist from MOT defect statistics — not a full service history or manufacturer service-bulletin list.
No. MOT tests do not cover engine internals, gearboxes, or many electronic modules. Patterns here come from MOT defect statistics only and should not be read as engine or gearbox reliability scores.
About this data
How this page is built and what it can (and can't) say.
These figures come from UK MOT open data for this model year. We surface common failure patterns against similar cars — not a full reliability score, and not a pass/fail verdict on any individual vehicle.
20242025
What we include
UK Class 4 cars only. Normal MOT tests (not retests); first test per vehicle per calendar year; results pass, PRS, or fail.
Same-day repairs
PRS means the car failed items that were fixed at the test station and then passed the same day. We count PRS as a first-attempt fail in headline rates so same-day repairs do not hide problems.
How we compare
We compare this model year with other Class 4 cars of similar age and mileage in the same test year. This model family is left out of the peer group so the car is not measured against itself.
What this does not cover
MOTs do not cover engine internals, gearboxes, or many electronics — this is not a full reliability score.
Common faults come from MOT defect stats, not manufacturer TSBs or recalls.
Age and mileage matching reduces — but does not remove — differences in how cars were used and maintained.
We never invent pass rates, star scores, or ranks when those data marts are missing.