Model Reports 4 min read Updated 18 Oct 2026

Toyota Yaris 2019: reliability & common MOT faults

In 2025, 86 in every 100 first MOTs on a 2019 Toyota Yaris were passes. Most common reason for a fail: Wheel bearings (rear).

Summary

The 2019 Toyota Yaris follows the pattern of the model years either side.

At a glance

How 27,244 first tests went in 2025.

Passed first time
86 in every 100
Did not pass first time
14 in every 1003,740 failed first-attempt tests
The typical car
6 yearsabout 31,260 miles
First tests counted
27,244

What failed most often

  1. Wheel bearings (rear)17 in every 100 failed tests
  2. Windscreen wipers (front)11 in every 100 failed tests
  3. Tyre condition (front)9 in every 100 failed tests

How we count this. Data: UK MOT open data, 2025. Only Class 4 cars on their first MOT of the year are counted. A car that fails and is fixed at the test station still counts as a fail in the first-attempt rate. These are raw results, not adjusted for age, mileage, or peer mix. The MOT does not test engine or gearbox internals.

Note:

These are patterns across 2019 Toyota Yaris vehicles in 2025, not a prediction that any one car will have them. Faults are grouped by part of the car. They come from MOT defect codes, not manufacturer bulletins, recalls or a diagnosis of any one car.

Suspension

One fault: wheel bearings (rear), 152 times as often as on similar cars.

Figures below are measured across the 3,739 of 3,740 failed first attempts that recorded an odometer reading in 2025. Mileage is needed to compare like with like.

We only list faults with at least 20 failures and a rate of about 2.0 times that of similar cars, which keeps one-off results out of the list.

Wheel bearings (rear)

Failed on 621 first tests152 times as often as similar carsStrong evidence

What it means

Excessive play in a wheel bearing, or a bearing that is excessively rough, is Major. Play so excessive that the bearing is likely to break up or directional control is impaired is Dangerous, and so is a bearing so rough that it is likely to overheat or break up.

Also noted as an advisory

Testers also noted it as an advisory, worn but not yet failing, on 127 first tests, 43 times as often as on similar cars.

Data: UK MOT open data, 2025. Compared with cars of the same age and mileage. Advisories count notes recorded on failed first tests only.

Lamps and electrical

One fault: side repeater indicators, 5.9 times as often as on similar cars.

Side repeater indicators

Failed on 221 first tests5.9 times as often as similar carsStrong evidence

What it means

Sequential or dynamic direction indicators are not a reason to fail. Where a side repeater is required, it is allowed to be part of the front direction indicator if it has a marked wraparound lens, or an amber light coming through the front lens when viewed from a set distance to the side of the rear bumper. A lens defect with no effect on the emitted light is Minor, and one that adversely affects the light is Major.

Data: UK MOT open data, 2025. Compared with cars of the same age and mileage.

Brakes

One fault: handbrake efficiency below minimum (roller test), 2.3 times as often as on similar cars.

Handbrake efficiency below minimum (roller test)

Failed on 102 first tests2.3 times as often as similar carsPossible evidence

What it means

A parking brake with efficiency below the minimum requirement is Major, and graded Dangerous where efficiency is less than half of the required value. On a roller brake tester, the requirement counts as met if more than half of the wheels of a brake system lock. The check applies only to vehicles whose parking brake was not already tested as the secondary brake.

Data: UK MOT open data, 2025. Compared with cars of the same age and mileage.

Advisories

Other things testers noted as worn or close to failing, more often than on similar cars.

An advisory is a note from the tester about something that has not failed yet. It is an early warning, not a fail. Advisories for the faults above are shown with those faults.

Suspension arm (front)

Noted on 33 first tests20 times as often as similar carsElevated evidence

Wheel bearings (front)

Noted on 20 first tests3.6 times as often as similar carsLikely evidence

Data: UK MOT open data, 2025. Counts cover advisories recorded on failed first tests only, compared with cars of the same age and mileage.

MOT pass rates

How first tests ended, and how the pass rates are counted.

Passed first time
86in every 100
Passed on the first test.
Fixed at the station
4in every 100
Failed, then fixed at the test station the same day.
Failed
10in every 100
Did not pass, and were not fixed at the test station.

First-attempt pass 86.3% of 27,244 first tests (2025): only cars that passed first time count. Official-style pass 90.4%: cars fixed at the test station also count as a pass. The 4 fixed and the 10 not fixed make the 14 in every 100 that did not pass first time.

By fuel type

First testsTypical mileagePassed first time, as testedPassed first time, same mileage
Petrol14,24731,001 miles8787
Hybrid12,99731,571 miles8686

Figures are in every 100 first tests. Cars with more miles usually fail more often, so the same-mileage figure gives every fuel the mileage mix of all the cars in this year.

Same model, other years

Passed first time in every 100, all tested in 2025.

40608010020002005201020152019Older carsNewer cars
406080100200020102019Older cars

Newer cars are younger, so look for a jump rather than the climb. A year earlier (2024), when these cars were a year younger, 87 in every 100 passed first time.

YearPassed first timeFirst tests
199952 in every 100789
200055 in every 1002,689
200155 in every 1005,605
200256 in every 1007,169
200353 in every 1009,228
200454 in every 10011,038
200554 in every 10013,843
200654 in every 10014,734
200755 in every 10018,423
200856 in every 10020,176
200963 in every 10023,051
201062 in every 10017,516
201166 in every 10015,471
201267 in every 10026,595
201369 in every 10028,189
201472 in every 10028,423
201579 in every 10030,019
201681 in every 10027,852
201781 in every 10026,164
201884 in every 10027,274
2019 This car86 in every 10027,244
202088 in every 10020,094
202191 in every 10023,209
202292 in every 10020,982

If you are buying one

What this year's MOT record means for the decision in front of you.

Mileage matters most on a 2019 Yaris.

Of 2019 Yaris vehicles with under 19,000 miles, 91 in every 100 passed their 2025 MOT first time. With 48,000 miles or more, 78 in every 100 did.

Under 19,0005,548 tests
91
19,000–27,0005,302 tests
91
27,000–36,000 Typical car5,671 tests
88
36,000–48,0005,355 tests
83
48,000 and over5,366 tests
78

What to check at your mileage

How often each fault turned up on a failed first test, by the car's mileage. Read it as: what is likely to need looking at on a car like the one in front of you.

Under 19,00027,000–36,00048,000 and over
Wheel bearings (rear)0.11.65.3
Windscreen wipers (front)2.31.41.1
Tyre condition (front)1.01.21.9
Tyre tread depth (front)0.30.71.7
Side repeater indicators0.60.81.3

Faults per 100 first tests, by the car's mileage at the test.

When a car fails

60in every 100

of failed cars had one item to fix.

15in every 100

of failed cars had three or more items to fix.

3in every 100

of all first tests had a defect the tester marked dangerous (unsafe to drive away).

Every figure here is a first-attempt MOT rate from DVSA open data for this model line, for cars of this model year tested in 2025. Each mileage band holds a fifth of the tests. MOTs do not test engine or gearbox internals, so this is a pre-purchase checklist, not a full reliability score.

FAQs

Short answers about how to read this model-year guide.

The 2019 Toyota Yaris follows the pattern of the model years either side. Its main cause of failure was Wheel bearings (rear), about 17 in every 100 failed tests. In 2025, 86.3% of 27,244 first MOTs on the 2019 Toyota Yaris passed first time (PRS: items fixed at the station the same day, counted as a fail). The official-style rate including PRS is 90.4%. Among 3,740 failed first-attempt MOT tests (test year 2025), Wheel bearings (rear) appears more often than on similar cars (16.6% of those tests; 621 observed failures; about 152× more often than similar cars). There is no single reliability score here; this is a pre-purchase checklist built from DVSA open data, not a guarantee for any individual car.
Ranked by how often they were actually recorded, the items that most often failed a 2019 Toyota Yaris at the first attempt were Wheel bearings (rear) (16.6%), Windscreen wipers (front) (11.0%) and Tyre condition (front) (9.4%), each as a share of the year's failed first attempts. That is what goes wrong most often on the car. The common faults table shows a different measure: faults that are unusual compared with similar cars.
Among failed first-attempt tests we highlight patterns that appear more often than on similar cars. Top example: Wheel bearings (rear) (16.6% of those tests; 621 observed failures; about 152× more often than similar cars). These are statistical signals, not a diagnosis of any individual car.
Wheel bearings (rear) shows up more often than on similar cars (16.6% of those tests; 621 observed failures; about 152× more often than similar cars). That does not prove a design fault. Age, mileage, and how the car was used still matter. Treat it as a pre-purchase checkpoint, not a manufacturer service bulletin.
Common MOT problem areas for the 2019 Toyota Yaris include Wheel bearings (rear), Side repeater indicators, Handbrake efficiency below minimum (roller test). These are the faults that stand out compared with similar cars, not a complete list of what can go wrong on any individual car.
Advisories flag issues noted at the test and are not a fail rate. We show advisory patterns that appear more often than on similar cars among failed first-attempt tests, separate from common failure rows. Use them as early-warning checks, not as a pass/fail score.
This page highlights MOT failure patterns for the 2019 Toyota Yaris (registration year) using UK DVSA open data for the selected test year. Patterns are compared with cars of a similar age and mileage. It is a buyer checklist from MOT defect statistics, not a full service history or manufacturer service-bulletin list.
No. MOT tests do not cover engine internals, gearboxes, or many electronic modules. Patterns here come from MOT defect statistics only and should not be read as engine or gearbox reliability scores.

About this data

How this page is built and what it can (and can't) say.

These figures come from UK MOT open data for this model year. We surface common failure patterns against similar cars, not a full reliability score, and not a pass/fail verdict on any individual vehicle.

2024 2025

What we include

UK Class 4 cars only. Normal MOT tests (not retests); first test per vehicle per calendar year; results pass, PRS, or fail.

Same-day repairs

PRS means the car failed items that were fixed at the test station and then passed the same day. We count PRS as a first-attempt fail in headline rates so same-day repairs do not hide problems.

How we compare

We compare this model year with other Class 4 cars of similar age and mileage in the same test year. This model family is left out of the peer group so the car is not measured against itself.

What this does not cover

  • MOTs do not cover engine internals, gearboxes, or many electronics; this is not a full reliability score.
  • Common faults come from MOT defect stats, not manufacturer TSBs or recalls.
  • Age and mileage matching reduces, but does not remove, differences in how cars were used and maintained.
  • If the data for a car is too thin to say anything useful, we say so rather than guess.

Contains public sector information licensed under the Open Government Licence v3.0.

Check any vehicle’s MOT history

Full MOT history, mileage records, and reliability insights for any UK vehicle.

Run a free check