At a glance
How 7,490 first tests went in 2025.
- Passed first time
- 69 in every 100
- Did not pass first time
- 31 in every 1002,293 failed first-attempt tests
- The typical car
- 8 yearsabout 118,675 miles
- First tests counted
- 7,490
What failed most often
- Diesel engine warning light15 in every 100 failed tests
- Coil spring (rear)15 in every 100 failed tests
- Handbrake efficiency below minimum (roller test)14 in every 100 failed tests
How we count this. Data: UK MOT open data, 2025. Only Class 4 cars on their first MOT of the year are counted. A car that fails and is fixed at the test station still counts as a fail in the first-attempt rate. These are raw results, not adjusted for age, mileage, or peer mix. The MOT does not test engine or gearbox internals.
These are patterns across 2017 Mercedes-Benz Vito vehicles in 2025, not a prediction that any one car will have them. Faults are grouped by part of the car. They come from MOT defect codes, not manufacturer bulletins, recalls or a diagnosis of any one car.
Brakes
Four faults. The strongest is the handbrake efficiency below minimum (roller test): 4.4 times as often as on similar cars.
Figures below are measured across the 2,286 of 2,293 failed first attempts (99.7%) that recorded an odometer reading in 2025. Mileage is needed to compare like with like.
We only list faults with at least 20 failures and a rate of about 2.0 times that of similar cars, which keeps one-off results out of the list.
Handbrake efficiency below minimum (roller test)
What it means
A parking brake with efficiency below the minimum requirement is Major, and graded Dangerous where efficiency is less than half of the required value. On a roller brake tester, the requirement counts as met if more than half of the wheels of a brake system lock. The check applies only to vehicles whose parking brake was not already tested as the secondary brake.
Handbrake lever
Handbrake performance (roller test, rear)
Electronic stability control
What it means
An ESC warning lamp is failed only when the tester is certain it indicates an ESC malfunction, because the lamp takes various forms and the owner's handbook may need checking. The system is also called ESP, VDC or DSC, among many other names. Every failure row is Major, covering the lamp, wheel speed sensors, wiring, other components and the switch.
Data: UK MOT open data, 2025. Compared with cars of the same age and mileage.
Suspension
Three faults. The strongest is the coil spring (rear): 3.5 times as often as on similar cars.
Coil spring (rear)
What it means
A missing bump stop rubber is not a reason to fail a coil spring. When the vehicle is jacked and lowered, a spring that does not correctly locate as the suspension returns to its normal running position is rejected as insecurely attached. A missing spring is Major, and graded Dangerous where directional control is affected.
Coil spring (front)
What it means
A missing bump stop rubber is not a reason to fail a coil spring. When the vehicle is jacked and lowered, a spring that does not correctly locate as the suspension returns to its normal running position is rejected as insecurely attached. A missing spring is Major, and graded Dangerous where directional control is affected.
Suspension arm ball joint (front)
What it means
A suspension arm ball joint is failed under the general suspension pin, bush or joint wording. Excessively worn is Major, and likely to become detached is graded Dangerous.
Also noted as an advisory
Testers also noted it as an advisory, worn but not yet failing, on 92 first tests, 2.0 times as often as on similar cars.
Data: UK MOT open data, 2025. Compared with cars of the same age and mileage. Advisories count notes recorded on failed first tests only.
Noise, emissions and leaks
One fault: diesel engine warning light, 3.0 times as often as on similar cars.
Diesel engine warning light
What it means
An engine malfunction indicator lamp that is illuminated to show a malfunction is graded Major on a diesel, but only on the diesels the test covers, which depends on the vehicle type and when it was first used. DVSA lists it under exhaust emissions for compression ignition engines, and the detail line for the row also names an inoperative lamp.
Data: UK MOT open data, 2025. Compared with cars of the same age and mileage.
Lamps and electrical
One fault: individual sidelight or tail light (rear), 2.0 times as often as on similar cars.
Individual sidelight or tail light (rear)
What it means
A position lamp showing red light to the front or white light to the rear is Major. Rear lamps must show a steady red light, and front ones can show white, predominantly white with a blue tinge, or yellow if combined in a yellow headlamp. With a multiple light source, up to half not working is Minor and more than half is Major.
Data: UK MOT open data, 2025. Compared with cars of the same age and mileage.
Advisories
Other things testers noted as worn or close to failing, more often than on similar cars.
An advisory is a note from the tester about something that has not failed yet. It is an early warning, not a fail. Advisories for the faults above are shown with those faults.
Transmission oil leaks
Data: UK MOT open data, 2025. Counts cover advisories recorded on failed first tests only, compared with cars of the same age and mileage.
MOT pass rates
How first tests ended, and how the pass rates are counted.
- Passed first time
- 69in every 100
- Passed on the first test.
- Fixed at the station
- 6in every 100
- Failed, then fixed at the test station the same day.
- Failed
- 25in every 100
- Did not pass, and were not fixed at the test station.
First-attempt pass 69.4% of 7,490 first tests (2025): only cars that passed first time count. Official-style pass 75.4%: cars fixed at the test station also count as a pass. The 6 fixed and the 25 not fixed make the 31 in every 100 that did not pass first time.
Same model, other years
Passed first time in every 100, all tested in 2025.
Newer cars are younger, so look for a jump rather than the climb. A year earlier (2024), when these cars were a year younger, 70 in every 100 passed first time.
| Year | Passed first time | First tests |
|---|---|---|
| 2003 | 45 in every 100 | 317 |
| 2004 | 51 in every 100 | 605 |
| 2005 | 52 in every 100 | 1,462 |
| 2006 | 56 in every 100 | 2,846 |
| 2007 | 55 in every 100 | 3,600 |
| 2008 | 57 in every 100 | 3,729 |
| 2009 | 60 in every 100 | 3,499 |
| 2010 | 60 in every 100 | 3,634 |
| 2011 | 61 in every 100 | 3,118 |
| 2012 | 63 in every 100 | 3,765 |
| 2013 | 63 in every 100 | 4,054 |
| 2014 | 65 in every 100 | 4,283 |
| 2015 | 67 in every 100 | 4,515 |
| 2016 | 68 in every 100 | 5,697 |
| 2017 This car | 69 in every 100 | 7,490 |
| 2018 | 71 in every 100 | 5,693 |
| 2019 | 73 in every 100 | 7,710 |
| 2020 | 74 in every 100 | 4,043 |
| 2021 | 76 in every 100 | 4,432 |
| 2022 | 83 in every 100 | 1,767 |
If you are buying one
What this year's MOT record means for the decision in front of you.
Mileage makes little difference on a 2017 Vito.
Of 2017 Vito vehicles with under 78,000 miles, 71 in every 100 passed their 2025 MOT first time. With 186,000 miles or more, 74 in every 100 did.
What to check at your mileage
How often each fault turned up on a failed first test, by the car's mileage. Read it as: what is likely to need looking at on a car like the one in front of you.
| Under 78,000 | 105,000–136,000 | 186,000 and over | |
|---|---|---|---|
| Diesel engine warning light | 3.9 | 5.6 | 3.9 |
| Coil spring (rear) | 5.5 | 4.8 | 2.3 |
| Handbrake efficiency below minimum (roller test) | 3.5 | 5.9 | 3.7 |
| Suspension arm ball joint (front) | 3.3 | 4.2 | 3.9 |
| Tyre pressure monitoring system | 1.7 | 1.8 | 1.8 |
Faults per 100 first tests, by the car's mileage at the test.
When a car fails
of failed cars had one item to fix.
of failed cars had three or more items to fix.
of all first tests had a defect the tester marked dangerous (unsafe to drive away).
Every figure here is a first-attempt MOT rate from DVSA open data for this model line, for cars of this model year tested in 2025. Each mileage band holds a fifth of the tests. MOTs do not test engine or gearbox internals, so this is a pre-purchase checklist, not a full reliability score.
FAQs
Short answers about how to read this model-year guide.
About this data
How this page is built and what it can (and can't) say.
These figures come from UK MOT open data for this model year. We surface common failure patterns against similar cars, not a full reliability score, and not a pass/fail verdict on any individual vehicle.
What we include
UK Class 4 cars only. Normal MOT tests (not retests); first test per vehicle per calendar year; results pass, PRS, or fail.
Same-day repairs
PRS means the car failed items that were fixed at the test station and then passed the same day. We count PRS as a first-attempt fail in headline rates so same-day repairs do not hide problems.
How we compare
We compare this model year with other Class 4 cars of similar age and mileage in the same test year. This model family is left out of the peer group so the car is not measured against itself.
What this does not cover
- MOTs do not cover engine internals, gearboxes, or many electronics; this is not a full reliability score.
- Common faults come from MOT defect stats, not manufacturer TSBs or recalls.
- Age and mileage matching reduces, but does not remove, differences in how cars were used and maintained.
- If the data for a car is too thin to say anything useful, we say so rather than guess.
Contains public sector information licensed under the Open Government Licence v3.0.
Check any vehicle’s MOT history
Full MOT history, mileage records, and reliability insights for any UK vehicle.
Run a free check