At a glance
How 3,365 first tests went in 2025.
- Passed first time
- 70 in every 100
- Did not pass first time
- 30 in every 100998 failed first-attempt tests
- The typical car
- 12 yearsabout 117,886 miles
- First tests counted
- 3,365
What failed most often
- Tyre condition (rear)12 in every 100 failed tests
- Brake pads (rear)11 in every 100 failed tests
- Track rod end (front)9 in every 100 failed tests
How we count this. Data: UK MOT open data, 2025. Only Class 4 cars on their first MOT of the year are counted. A car that fails and is fixed at the test station still counts as a fail in the first-attempt rate. These are raw results, not adjusted for age, mileage, or peer mix. The MOT does not test engine or gearbox internals.
These are patterns across 2013 Volvo V60 vehicles in 2025, not a prediction that any one car will have them. Faults are grouped by part of the car. A wear pattern follows age and use more than the way the car was built. They come from MOT defect codes, not manufacturer bulletins, recalls or a diagnosis of any one car.
Brakes
One fault and one wear pattern. The strongest is the brake pedal: 5.0 times as often as on similar cars.
Figures below are measured across the 997 of 998 failed first attempts (99.9%) that recorded an odometer reading in 2025. Mileage is needed to compare like with like.
We only list faults with at least 20 failures and a rate of about 2.0 times that of similar cars, which keeps one-off results out of the list.
Brake pedal
What it means
A brake pedal rubber worn smooth is not a defect, and nor is a worn design pattern on an aftermarket rubber. A pedal with no rubber is rejected if its grooves or raised grip sections are worn smooth, unless the vehicle was made without them. Insufficient reserve travel is Major, but a vehicle is failed for it only if the pedal or lever is touching the floor or handlebar.
Brake pads (rear)
What it means
A pad worn down to its wear indicator, or contaminated with oil or grease, is Major. A pad worn below the set thickness limit, missing or incorrectly mounted is Dangerous. The manual treats an illuminated brake wear indicator as no reason for failure, although DVSA also lists an illuminated indicator as a Major row.
Data: UK MOT open data, 2025. Compared with cars of the same age and mileage.
Suspension
Two faults. The strongest is the shock absorbers (front): 4.3 times as often as on similar cars.
Shock absorbers (front)
What it means
Slight seepage that leaves a film of fluid on a shock absorber does not fail it. Severe leakage, or damage so that it does not function, is Major. A shock absorber missing or likely to become detached is graded Dangerous, though a missing one is only rejected if shock absorbers were fitted as standard.
Suspension arm pins and bushes (rear)
What it means
Pins and bushes on suspension arms fail as Major when they are excessively worn. They are graded Dangerous when likely to become detached. DVSA uses the same wording for a suspension joint.
Also noted as an advisory
Testers also noted it as an advisory, worn but not yet failing, on 52 first tests, 2.5 times as often as on similar cars.
Data: UK MOT open data, 2025. Compared with cars of the same age and mileage. Advisories count notes recorded on failed first tests only.
Tyres
One wear pattern: tyre condition (rear), 2.1 times as often as on similar cars.
Tyre condition (rear)
What it means
Exposed or damaged ply or cords are graded Dangerous. A cut in excess of the requirements and deep enough to reach the ply or cords is Major, and testers may open the cut with a blunt instrument to check its depth. A tyre contacting the vehicle through flexing or suspension movement is not a defect; fouling fails only at the time of test.
Data: UK MOT open data, 2025. Compared with cars of the same age and mileage.
Advisories
Other things testers noted as worn or close to failing, more often than on similar cars.
An advisory is a note from the tester about something that has not failed yet. It is an early warning, not a fail. Advisories for the faults above are shown with those faults.
Coil spring (rear)
Number plates (rear)
Data: UK MOT open data, 2025. Counts cover advisories recorded on failed first tests only, compared with cars of the same age and mileage.
MOT pass rates
How first tests ended, and how the pass rates are counted.
- Passed first time
- 70in every 100
- Passed on the first test.
- Fixed at the station
- 4in every 100
- Failed, then fixed at the test station the same day.
- Failed
- 26in every 100
- Did not pass, and were not fixed at the test station.
First-attempt pass 70.3% of 3,365 first tests (2025): only cars that passed first time count. Official-style pass 74.3%: cars fixed at the test station also count as a pass. The 4 fixed and the 26 not fixed make the 30 in every 100 that did not pass first time.
Same model, other years
Passed first time in every 100, all tested in 2025.
Newer cars are younger, so look for a jump rather than the climb. A year earlier (2024), when these cars were a year younger, 72 in every 100 passed first time.
| Year | Passed first time | First tests |
|---|---|---|
| 2011 | 68 in every 100 | 2,307 |
| 2012 | 68 in every 100 | 4,244 |
| 2013 This car | 70 in every 100 | 3,365 |
| 2014 | 71 in every 100 | 3,433 |
| 2015 | 75 in every 100 | 3,164 |
| 2016 | 77 in every 100 | 3,647 |
| 2017 | 75 in every 100 | 3,055 |
| 2018 | 83 in every 100 | 3,761 |
| 2019 | 83 in every 100 | 4,595 |
| 2020 | 86 in every 100 | 2,969 |
| 2021 | 87 in every 100 | 3,516 |
| 2022 | 88 in every 100 | 1,406 |
If you are buying one
What this year's MOT record means for the decision in front of you.
Mileage matters most on a 2013 Volvo V60.
Of 2013 Volvo V60 vehicles with under 85,000 miles, 79 in every 100 passed their 2025 MOT first time. With 153,000 miles or more, 64 in every 100 did.
What to check at your mileage
How often each fault turned up on a failed first test, by the car's mileage. Read it as: what is likely to need looking at on a car like the one in front of you.
| Under 85,000 | 108,000–128,000 | 153,000 and over | |
|---|---|---|---|
| Tyre condition (rear) | 2.8 | 3.1 | 5.6 |
| Brake pads (rear) | 2.2 | 2.4 | 4.9 |
| Track rod end (front) | 1.9 | 3.0 | 2.8 |
| Shock absorbers (front) | 0.7 | 3.6 | 2.6 |
| Tyre tread depth (front) | 1.6 | 2.1 | 2.1 |
Faults per 100 first tests, by the car's mileage at the test.
When a car fails
of failed cars had one item to fix.
of failed cars had three or more items to fix.
of all first tests had a defect the tester marked dangerous (unsafe to drive away).
Every figure here is a first-attempt MOT rate from DVSA open data for this model line, for cars of this model year tested in 2025. Each mileage band holds a fifth of the tests. MOTs do not test engine or gearbox internals, so this is a pre-purchase checklist, not a full reliability score.
FAQs
Short answers about how to read this model-year guide.
About this data
How this page is built and what it can (and can't) say.
These figures come from UK MOT open data for this model year. We surface common failure patterns against similar cars, not a full reliability score, and not a pass/fail verdict on any individual vehicle.
What we include
UK Class 4 cars only. Normal MOT tests (not retests); first test per vehicle per calendar year; results pass, PRS, or fail.
Same-day repairs
PRS means the car failed items that were fixed at the test station and then passed the same day. We count PRS as a first-attempt fail in headline rates so same-day repairs do not hide problems.
How we compare
We compare this model year with other Class 4 cars of similar age and mileage in the same test year. This model family is left out of the peer group so the car is not measured against itself.
What this does not cover
- MOTs do not cover engine internals, gearboxes, or many electronics; this is not a full reliability score.
- Common faults come from MOT defect stats, not manufacturer TSBs or recalls.
- Age and mileage matching reduces, but does not remove, differences in how cars were used and maintained.
- If the data for a car is too thin to say anything useful, we say so rather than guess.
Contains public sector information licensed under the Open Government Licence v3.0.
Check any vehicle’s MOT history
Full MOT history, mileage records, and reliability insights for any UK vehicle.
Run a free check