At a glance
How 10,374 first tests went in 2025.
- Passed first time
- 56 in every 100
- Did not pass first time
- 44 in every 1004,571 failed first-attempt tests
- The typical car
- 14 yearsabout 105,410 miles
- First tests counted
- 10,374
What failed most often
- Tyre condition (front)10 in every 100 failed tests
- Suspension arm pins and bushes (front)10 in every 100 failed tests
- Coil spring (rear)9 in every 100 failed tests
How we count this. Data: UK MOT open data, 2025. Only Class 4 cars on their first MOT of the year are counted. A car that fails and is fixed at the test station still counts as a fail in the first-attempt rate. These are raw results, not adjusted for age, mileage, or peer mix. The MOT does not test engine or gearbox internals.
These are patterns across 2011 Vauxhall Zafira vehicles in 2025, not a prediction that any one car will have them. Faults are grouped by part of the car. A wear pattern follows age and use more than the way the car was built. They come from MOT defect codes, not manufacturer bulletins, recalls or a diagnosis of any one car.
Suspension
Two faults. The strongest is the swivel pins and bushes (rear): 7.7 times as often as on similar cars.
Figures below are measured across the 4,566 of 4,571 failed first attempts (99.9%) that recorded an odometer reading in 2025. Mileage is needed to compare like with like.
We only list faults with at least 20 failures and a rate of about 2.0 times that of similar cars, which keeps one-off results out of the list.
Swivel pins and bushes (rear)
Also noted as an advisory
Testers also noted it as an advisory, worn but not yet failing, on 289 first tests, 7.5 times as often as on similar cars.
Coil spring (rear)
What it means
A missing bump stop rubber is not a reason to fail a coil spring. When the vehicle is jacked and lowered, a spring that does not correctly locate as the suspension returns to its normal running position is rejected as insecurely attached. A missing spring is Major, and graded Dangerous where directional control is affected.
Data: UK MOT open data, 2025. Compared with cars of the same age and mileage. Advisories count notes recorded on failed first tests only.
Brakes
Two wear patterns. The strongest is the brake discs (rear): 2.7 times as often as on similar cars.
Brake discs (rear)
What it means
A brake disc or drum must be significantly worn before it is rejected, and being worn below the manufacturer's recommended limits is not a reason in itself. Significantly and obviously worn is Major, as is contamination with oil or grease. A disc or drum that is fractured, insecure, seriously weakened or missing is graded Dangerous.
Brake pads (rear)
What it means
A pad worn down to its wear indicator, or contaminated with oil or grease, is Major. A pad worn below the set thickness limit, missing or incorrectly mounted is Dangerous. The manual treats an illuminated brake wear indicator as no reason for failure, although DVSA also lists an illuminated indicator as a Major row.
Data: UK MOT open data, 2025. Compared with cars of the same age and mileage.
Lamps and electrical
Two faults. The strongest is the individual direction indicators (rear): 2.6 times as often as on similar cars.
Individual direction indicators (rear)
What it means
Direction indicators must be amber, though vehicles first used before a set date may have white at the front and red at the rear when the indicators are combined with stop or position lamps, and sequential or dynamic ones are not a reason to fail. A lamp that is missing, inoperative or has more than half of a multiple light source not functioning is graded Major. A flashing rate outside the permitted range is graded Minor.
Also noted as an advisory
Testers also noted it as an advisory, worn but not yet failing, on 212 first tests, 2.6 times as often as on similar cars.
Horn
What it means
A horn that does not work, or is likely to be confused with an emergency vehicle siren, is graded Major. Gongs, bells, sirens and anything with more than one tone, which includes a horn that alternates between its notes, are not allowed, except a gong, bell or siren on vehicles first used before a set date. Sound defects are Minor for named cases such as a bell or harsh sound, and Major under a general row.
Data: UK MOT open data, 2025. Compared with cars of the same age and mileage. Advisories count notes recorded on failed first tests only.
Noise, emissions and leaks
One fault: petrol engine warning light, 2.1 times as often as on similar cars.
Petrol engine warning light
What it means
The malfunction indicator lamp (MIL) on a petrol engine is a Major failure when it is illuminated indicating a malfunction. The detail line DVSA gives for the same row also names an inoperative lamp. The test covers only certain petrol vehicles, depending on their age, size and fuel type.
Data: UK MOT open data, 2025. Compared with cars of the same age and mileage.
Advisories
Other things testers noted as worn or close to failing, more often than on similar cars.
An advisory is a note from the tester about something that has not failed yet. It is an early warning, not a fail. Advisories for the faults above are shown with those faults.
Suspension sub-frame mounting area (front)
Suspension sub-frame pins and bushes (rear)
Seat belt condition (rear)
Flexible brake hoses (front)
Other suspension component pins and bushes (rear)
Suspension mounting area (front)
Engine oil leaks (front)
Data: UK MOT open data, 2025. Counts cover advisories recorded on failed first tests only, compared with cars of the same age and mileage.
MOT pass rates
How first tests ended, and how the pass rates are counted.
- Passed first time
- 56in every 100
- Passed on the first test.
- Fixed at the station
- 9in every 100
- Failed, then fixed at the test station the same day.
- Failed
- 35in every 100
- Did not pass, and were not fixed at the test station.
First-attempt pass 55.9% of 10,374 first tests (2025): only cars that passed first time count. Official-style pass 64.9%: cars fixed at the test station also count as a pass. The 9 fixed and the 35 not fixed make the 44 in every 100 that did not pass first time.
Petrol and diesel
Figures are in every 100 first tests. Cars with more miles usually fail more often, so the same-mileage figure gives every fuel the mileage mix of all the cars in this year.
Same model, other years
Passed first time in every 100, all tested in 2025.
Newer cars are younger, so look for a jump rather than the climb.
| Year | Passed first time | First tests |
|---|---|---|
| 2001 | 55 in every 100 | 500 |
| 2002 | 53 in every 100 | 1,011 |
| 2003 | 52 in every 100 | 1,665 |
| 2004 | 52 in every 100 | 2,822 |
| 2005 | 51 in every 100 | 3,730 |
| 2006 | 53 in every 100 | 5,180 |
| 2007 | 50 in every 100 | 8,100 |
| 2008 | 52 in every 100 | 9,685 |
| 2009 | 52 in every 100 | 7,162 |
| 2010 | 55 in every 100 | 12,982 |
| 2011 This car | 56 in every 100 | 10,374 |
| 2012 | 60 in every 100 | 13,902 |
| 2013 | 62 in every 100 | 24,790 |
| 2014 | 65 in every 100 | 25,167 |
| 2015 | 69 in every 100 | 13,395 |
| 2016 | 70 in every 100 | 10,864 |
| 2017 | 73 in every 100 | 11,209 |
| 2018 | 77 in every 100 | 4,555 |
If you are buying one
What this year's MOT record means for the decision in front of you.
Mileage matters most on a 2011 Zafira.
Of 2011 Zafira vehicles with under 81,000 miles, 66 in every 100 passed their 2025 MOT first time. With 131,000 miles or more, 50 in every 100 did.
Petrol or diesel?
| Typical mileage | Passed first time, as tested | Passed first time, same mileage | |
|---|---|---|---|
| Petrol | 98,758 miles | 57 | 56 |
| Diesel | 113,432 miles | 55 | 56 |
Figures are in every 100 first tests. Petrol cars look better on the raw figures only because diesel cars have done more miles (typically 113,432 against 98,758). At the same mileage there is no clear difference between the two.
What to check at your mileage
How often each fault turned up on a failed first test, by the car's mileage. Read it as: what is likely to need looking at on a car like the one in front of you.
| Under 81,000 | 98,000–113,000 | 131,000 and over | |
|---|---|---|---|
| Tyre condition (front) | 2.6 | 4.8 | 5.0 |
| Suspension arm pins and bushes (front) | 1.7 | 4.8 | 6.1 |
| Coil spring (rear) | 3.5 | 4.2 | 4.3 |
| Windscreen washers | 3.0 | 3.8 | 3.6 |
| Individual sidelight or tail light (front) | 1.5 | 3.4 | 6.3 |
Faults per 100 first tests, by the car's mileage at the test.
When a car fails
of failed cars had one item to fix.
of failed cars had three or more items to fix.
of all first tests had a defect the tester marked dangerous (unsafe to drive away).
Every figure here is a first-attempt MOT rate from DVSA open data for this model line, for cars of this model year tested in 2025. Each mileage band holds a fifth of the tests. MOTs do not test engine or gearbox internals, so this is a pre-purchase checklist, not a full reliability score.
FAQs
Short answers about how to read this model-year guide.
About this data
How this page is built and what it can (and can't) say.
These figures come from UK MOT open data for this model year. We surface common failure patterns against similar cars, not a full reliability score, and not a pass/fail verdict on any individual vehicle.
What we include
UK Class 4 cars only. Normal MOT tests (not retests); first test per vehicle per calendar year; results pass, PRS, or fail.
Same-day repairs
PRS means the car failed items that were fixed at the test station and then passed the same day. We count PRS as a first-attempt fail in headline rates so same-day repairs do not hide problems.
How we compare
We compare this model year with other Class 4 cars of similar age and mileage in the same test year. This model family is left out of the peer group so the car is not measured against itself.
What this does not cover
- MOTs do not cover engine internals, gearboxes, or many electronics; this is not a full reliability score.
- Common faults come from MOT defect stats, not manufacturer TSBs or recalls.
- Age and mileage matching reduces, but does not remove, differences in how cars were used and maintained.
- If the data for a car is too thin to say anything useful, we say so rather than guess.
Contains public sector information licensed under the Open Government Licence v3.0.
Check any vehicle’s MOT history
Full MOT history, mileage records, and reliability insights for any UK vehicle.
Run a free check