Model Reports 8 min read Updated 11 Sep 2026 DVSA open data · 2,822 tests analysed

Vauxhall Zafira 2004: reliability & common MOT faults

1,358 first-attempt MOT failures were recorded on the 2004 Vauxhall Zafira in 2025. Figures are among first-attempt failed MOT tests, not among all tests.

Malfunction indicator lamp was the most common reason a 2004 Zafira failed its MOT — 11.5% of its failed first attempts.

First-attempt pass

51.9%

of 2,822 first tests (2025)

First tests

2,822

test year 2025

Failed first attempts

1,358

failed first-attempt tests

MOT pass rates

First-attempt and official-style rates among class 4 first tests of the year.

First-attempt pass

51.9%

of 2,822 first tests (2025)

Official-style pass

62.7%

incl. same-day PRS fixes

First tests

2,822

class 4 · first MOT of the year

Typical age 21.0 yrs · median mileage 112,521 mi

vs 2024: -0.1 pp first-attempt

Note:

  • Class 4 cars · first MOT of the year per vehicle · P/PRS/F outcomes (2025 data).
  • PRS (fixed at the station the same day) counts as a fail in the first-attempt rate.
  • Raw outcomes for this cohort — not adjusted for age, mileage, or peer mix.
  • MOT doesn't test engine or gearbox internals.

Common faults

Failure patterns that show up more often on this registration year than on similar cars.

These MOT failure patterns show up more often on this registration year than on similar cars of the same class, age, and mileage.

Shares below are measured across the 1,289 of 1,358 failed first attempts (94.9%) that recorded an odometer reading in 2025 — the subset the age-and-mileage comparison can be computed on. 5.1% of failures are excluded for want of a mileage reading, so treat these shares as indicative for this model year.

Standout: Sub-frame mounting prescribed areas (front) — 2.4% of this year's failed first attempts

Recorded on 31 of those tests. It tops the table on elevation — about 6.6× more often than on similar cars of the same age and mileage. That is what makes it unusual for its class, which is a different question from what is most likely to fail; the buying checklist ranks by that. The full ranked list is in the table below.

No patterns met the strongest callout thresholds on this page; showing the highest-lift rows that still cleared the display floors.

Fault pattern Location Failures vs similar cars Share of fails Confidence
Sub-frame mounting prescribed areas (front)
Suspension > Sub-frames > Sub-frame mounting prescribed areas
 Front 31 ×6.6 2.4% Likely
Rigid brake pipes (front)
Brakes > Rigid brake pipes
 Front 95 ×3.1 7.4% Likely
Shock absorbers (rear)
Suspension > Shock absorbers
 Rear 89 ×3.0 6.9% Likely
Coil spring (rear)
Suspension > Springs > Coil springs > Coil spring
 Rear 89 ×2.7 6.9% Possible
Exhaust system (rear)
Body, chassis, structure > Exhaust system
 Rear 75 ×2.3 5.8% Possible
Emissions not tested
Noise, emissions and leaks > Exhaust emissions > Spark ignition > Emissions not tested
 Any 64 ×2.2 5.0% Possible

Only patterns that clear minimum sample and elevation thresholds are shown (at least 20 failures and about 2.0× more often than similar cars).

Note: Rates and comparisons are among first-attempt failed tests, not all MOTs. Patterns come from MOT defect codes — not manufacturer service bulletins, recalls, or a diagnosis of any individual car. Failures and advisories are listed separately.

Wear patterns

Usage and mileage effects that often track road use rather than model design.

These patterns look like wear or usage effects rather than model-specific design faults. Tyres, brake friction material, and alignment-related defects often track mileage and road use.

Pattern Location Failures vs similar cars Share of fails Confidence
Brake pads (rear)
Brakes > Mechanical brake components > Brake linings and pads > Brake pads
 Rear 64 ×2.4 5.0% Wear
Brake discs (rear)
Brakes > Mechanical brake components > Brake discs and drums > Brake discs
 Rear 26 ×2.1 2.0% Wear
Note: These patterns are not treated as a model design fault in our common-faults ranking.

Advisories

Notes recorded at the test that appear more often than on similar cars.

Advisory notes recorded on failed first-attempt tests that appear more often than on similar cars.

Advisory pattern Location Notes vs similar cars Share Confidence
Sub-frame mounting prescribed areas (front)
Suspension > Sub-frames > Sub-frame mounting prescribed areas
 Front 59 ×9.7 4.6% Likely
Other components
Steering > Power steering > Other components
 Any 29 ×3.5 2.2% Elevated
Pedal
Brakes > Service brake pedal or hand lever > Pedal
 Any 20 ×3.3 1.6% Elevated
Individual direction indicators (rear)
Lamps, reflectors and electrical equipment > Direction indicators > Flashing type > Individual direction indicators
 Rear 42 ×2.8 3.3% Elevated
Sub-frame (front)
Suspension > Sub-frames > Sub-frame
 Front 74 ×2.2 5.7% Elevated
Shock absorbers (rear)
Suspension > Shock absorbers
 Rear 99 ×2.1 7.7% Likely
Rigid brake pipes (rear)
Brakes > Rigid brake pipes
 Rear 288 ×2.1 22.3% Elevated
Brake pads (rear)
Brakes > Mechanical brake components > Brake linings and pads > Brake pads
 Rear 82 ×2.0 6.4% Wear
Note: Advisories are not a fail rate — they flag issues noted at the test, often before they become failures.

If you are buying one

What this year's MOT record means for the decision in front of you.

Nothing separates this year from the Zafiras either side of it, so buy on the individual car. The checks below are the items that actually failed 2004 Zafiras, commonest first.

Other Zafira years worth knowing about

Newer cars always pass more often, so a plain "best year" list would just rank by age. These are the years that beat or miss the trend their own neighbouring years set — the only age-adjusted signal this data supports.

Year vs the years either side First-attempt pass (rises with newer cars) First tests
2007 Zafira -1.9 pp worse 50.1% 8,100

What to check on a 2004 Zafira

The items that failed 2004 Zafiras most often, as a share of the year's failed first attempts. This is what goes wrong, not what is unusual — the table further up the page covers that.

  • Malfunction indicator lamp — recorded on 11.5% of failed first attempts
  • Position lamp (front) — recorded on 10.6% of failed first attempts
  • Catalyst emissions — recorded on 8.5% of failed first attempts
  • Rbt (sp) — recorded on 8.2% of failed first attempts
  • Drive shafts — Joints (front) — recorded on 7.5% of failed first attempts

Every figure here is a first-attempt MOT rate from DVSA open data for this model line. MOTs do not test engine or gearbox internals, so this is a pre-purchase checklist, not a full reliability score.

FAQs

Short answers about how to read this model-year guide.

Malfunction indicator lamp was the most common reason a 2004 Zafira failed its MOT — 11.5% of its failed first attempts. In 2025, 51.9% of 2,822 first MOTs on the 2004 Vauxhall Zafira passed first time (PRS — items fixed at the station the same day — counted as a fail). The official-style rate including PRS is 62.7%. Among 1,358 failed first-attempt MOT tests (test year 2025), Sub-frame mounting prescribed areas (fr…
Ranked by how often they were actually recorded, the items that failed 2004 Vauxhall Zafiras most often at the first attempt were Malfunction indicator lamp (11.5%), Position lamp (front) (10.6%) and Catalyst emissions (8.5%) — each as a share of the year's failed first attempts. That is what goes wrong on the car. It is a different question from which patterns are unusual for the class, which the common-faults tabl…
Among failed first-attempt tests we highlight patterns that appear more often than on similar cars. Top example: Sub-frame mounting prescribed areas (front) (2.4% of those tests; 31 observed failures; about 6.6× more often than similar cars). These are statistical signals, not a diagnosis of any individual car.
Sub-frame mounting prescribed areas (front) shows up more often than on similar cars (2.4% of those tests; 31 observed failures; about 6.6× more often than similar cars). That does not prove a design fault — age, mileage, and how the car was used still matter. Treat it as a pre-purchase check point, not a manufacturer service bulletin.
Common MOT problem areas for the 2004 Vauxhall Zafira include Sub-frame mounting prescribed areas (front), Rigid brake pipes (front), Shock absorbers (rear). These patterns show up more often than on similar cars after we filter out sparse noise — not a full list of every possible fault on an individual car.
Advisories flag issues noted at the test and are not a fail rate. We show advisory patterns that appear more often than on similar cars among failed first-attempt tests, separate from common failure rows. Use them as early-warning checks, not as a pass/fail score.
This page highlights MOT failure patterns for the 2004 Vauxhall Zafira (registration year) using UK DVSA open data for the selected test year. Patterns are compared with cars of a similar age and mileage. It is a buyer checklist from MOT defect statistics — not a full service history or manufacturer service-bulletin list.
No. MOT tests do not cover engine internals, gearboxes, or many electronic modules. Patterns here come from MOT defect statistics only and should not be read as engine or gearbox reliability scores.

About this data

How this page is built and what it can (and can't) say.

These figures come from UK MOT open data for this model year. We surface common failure patterns against similar cars — not a full reliability score, and not a pass/fail verdict on any individual vehicle.

2024 2025

What we include

UK Class 4 cars only. Normal MOT tests (not retests); first test per vehicle per calendar year; results pass, PRS, or fail.

Same-day repairs

PRS means the car failed items that were fixed at the test station and then passed the same day. We count PRS as a first-attempt fail in headline rates so same-day repairs do not hide problems.

How we compare

We compare this model year with other Class 4 cars of similar age and mileage in the same test year. This model family is left out of the peer group so the car is not measured against itself.

What this does not cover

  • MOTs do not cover engine internals, gearboxes, or many electronics — this is not a full reliability score.
  • Common faults come from MOT defect stats, not manufacturer TSBs or recalls.
  • Age and mileage matching reduces — but does not remove — differences in how cars were used and maintained.
  • We never invent pass rates, star scores, or ranks when those data marts are missing.

Contains public sector information licensed under the Open Government Licence v3.0.

Check any vehicle’s MOT history

Full MOT history, mileage records, and reliability insights for any UK vehicle.

Run a free check