Model Reports 4 min read Updated 18 Oct 2026

Suzuki Wagon-R+ 2003: reliability & common MOT faults

In 2025, 55 in every 100 first MOTs on a 2003 Suzuki Wagon-R+ were passes. Most common reason for a fail: Individual sidelight or tail light (front).

Summary

The 2003 Suzuki Wagon-R+ follows the pattern of the model years either side.

At a glance

How 1,181 first tests went in 2025.

Passed first time
55 in every 100
Did not pass first time
45 in every 100537 failed first-attempt tests
The typical car
22 yearsabout 75,653 miles
First tests counted
1,181

What failed most often

  1. Individual sidelight or tail light (front)15 in every 100 failed tests
  2. Suspension arm ball joint (front)10 in every 100 failed tests
  3. Tyre condition (front)10 in every 100 failed tests

How we count this. Data: UK MOT open data, 2025. Only Class 4 cars on their first MOT of the year are counted. A car that fails and is fixed at the test station still counts as a fail in the first-attempt rate. These are raw results, not adjusted for age, mileage, or peer mix. The MOT does not test engine or gearbox internals.

Note:

These are patterns across 2003 Suzuki Wagon-R+ vehicles in 2025, not a prediction that any one car will have them. Faults are grouped by part of the car. A wear pattern follows age and use more than the way the car was built. They come from MOT defect codes, not manufacturer bulletins, recalls or a diagnosis of any one car.

Suspension

Three faults. The strongest is the wheel bearings (rear): 5.2 times as often as on similar cars.

Figures below are measured across the 534 of 537 failed first attempts (99.4%) that recorded an odometer reading in 2025. Mileage is needed to compare like with like.

We only list faults with at least 20 failures and a rate of about 2.0 times that of similar cars, which keeps one-off results out of the list.

Wheel bearings (rear)

Failed on 44 first tests5.2 times as often as similar carsLikely evidence

What it means

Excessive play in a wheel bearing, or a bearing that is excessively rough, is Major. Play so excessive that the bearing is likely to break up or directional control is impaired is Dangerous, and so is a bearing so rough that it is likely to overheat or break up.

Suspension arm ball joint (front)

Failed on 55 first tests2.5 times as often as similar carsPossible evidence

What it means

A suspension arm ball joint is failed under the general suspension pin, bush or joint wording. Excessively worn is Major, and likely to become detached is graded Dangerous.

Also noted as an advisory

Testers also noted it as an advisory, worn but not yet failing, on 29 first tests, 2.5 times as often as on similar cars.

Suspension arm ball joint dust cover (front)

Failed on 28 first tests2.1 times as often as similar carsPossible evidence

What it means

Whether a suspension arm ball joint dust cover still keeps dirt out decides its grade. Severely deteriorated is Minor, while missing, or no longer preventing the ingress of dirt, is Major.

Data: UK MOT open data, 2025. Compared with cars of the same age and mileage. Advisories count notes recorded on failed first tests only.

Tyres

One wear pattern: tyre condition (front), 2.0 times as often as on similar cars.

Tyre condition (front)

Failed on 54 first tests2.0 times as often as similar carsWear pattern

What it means

Exposed or damaged ply or cords are graded Dangerous. A cut in excess of the requirements and deep enough to reach the ply or cords is Major, and testers may open the cut with a blunt instrument to check its depth. A tyre contacting the vehicle through flexing or suspension movement is not a defect; fouling fails only at the time of test.

Data: UK MOT open data, 2025. Compared with cars of the same age and mileage.

Advisories

Other things testers noted as worn or close to failing, more often than on similar cars.

An advisory is a note from the tester about something that has not failed yet. It is an early warning, not a fail. Advisories for the faults above are shown with those faults.

Coil spring (front)

Noted on 68 first tests3.4 times as often as similar carsElevated evidence

Suspension arm (rear)

Noted on 39 first tests3.2 times as often as similar carsElevated evidence

Suspension arm pins and bushes (rear)

Noted on 21 first tests2.5 times as often as similar carsElevated evidence

Non-component advisories (front)

Noted on 61 first tests2.3 times as often as similar carsElevated evidence

Brake pads (front)

Noted on 48 first tests2.3 times as often as similar carsWear pattern

Suspension mounting area (rear)

Noted on 43 first tests2.2 times as often as similar carsElevated evidence

Flexible brake hoses (front)

Noted on 35 first tests2.0 times as often as similar carsElevated evidence

Data: UK MOT open data, 2025. Counts cover advisories recorded on failed first tests only, compared with cars of the same age and mileage.

MOT pass rates

How first tests ended, and how the pass rates are counted.

Passed first time
55in every 100
Passed on the first test.
Fixed at the station
8in every 100
Failed, then fixed at the test station the same day.
Failed
37in every 100
Did not pass, and were not fixed at the test station.

First-attempt pass 54.5% of 1,181 first tests (2025): only cars that passed first time count. Official-style pass 63.2%: cars fixed at the test station also count as a pass. The 8 fixed and the 37 not fixed make the 45 in every 100 that did not pass first time.

Same model, other years

Passed first time in every 100, all tested in 2025.

4060801002001200220032004200520062007Older carsNewer cars
4060801002003Older carsNewer cars

Newer cars are younger, so look for a jump rather than the climb. A year earlier (2024), when these cars were a year younger, 52 in every 100 passed first time.

YearPassed first timeFirst tests
200154 in every 100580
200250 in every 100886
2003 This car55 in every 1001,181
200457 in every 1001,262
200558 in every 1001,002
200660 in every 100447
200761 in every 100406

FAQs

Short answers about how to read this model-year guide.

The 2003 Suzuki Wagon-R+ follows the pattern of the model years either side. Its main cause of failure was Individual sidelight or tail light (front), about 15 in every 100 failed tests. In 2025, 54.5% of 1,181 first MOTs on the 2003 Suzuki Wagon-R+ passed first time (PRS: items fixed at the station the same day, counted as a fail). The official-style rate including PRS is 63.2%. Among 537 failed first-attempt MOT tests (test year 2025), Wheel bearings (rear) appears more often than on similar cars (8.2% of those tests; 44 observed failures; about 5.2× more often than similar cars). There is no single reliability score here; this is a pre-purchase checklist built from DVSA open data, not a guarantee for any individual car.
Ranked by how often they were actually recorded, the items that most often failed a 2003 Suzuki Wagon-R+ at the first attempt were Individual sidelight or tail light (front) (14.6%), Suspension arm ball joint (front) (10.3%) and Tyre condition (front) (10.1%), each as a share of the year's failed first attempts. That is what goes wrong most often on the car. The common faults table shows a different measure: faults that are unusual compared with similar cars.
Among failed first-attempt tests we highlight patterns that appear more often than on similar cars. Top example: Wheel bearings (rear) (8.2% of those tests; 44 observed failures; about 5.2× more often than similar cars). These are statistical signals, not a diagnosis of any individual car.
Wheel bearings (rear) shows up more often than on similar cars (8.2% of those tests; 44 observed failures; about 5.2× more often than similar cars). That does not prove a design fault. Age, mileage, and how the car was used still matter. Treat it as a pre-purchase checkpoint, not a manufacturer service bulletin.
Common MOT problem areas for the 2003 Suzuki Wagon-R+ include Wheel bearings (rear), Suspension arm ball joint (front), Suspension arm ball joint dust cover (front). These are the faults that stand out compared with similar cars, not a complete list of what can go wrong on any individual car.
Advisories flag issues noted at the test and are not a fail rate. We show advisory patterns that appear more often than on similar cars among failed first-attempt tests, separate from common failure rows. Use them as early-warning checks, not as a pass/fail score.
This page highlights MOT failure patterns for the 2003 Suzuki Wagon-R+ (registration year) using UK DVSA open data for the selected test year. Patterns are compared with cars of a similar age and mileage. It is a buyer checklist from MOT defect statistics, not a full service history or manufacturer service-bulletin list.
No. MOT tests do not cover engine internals, gearboxes, or many electronic modules. Patterns here come from MOT defect statistics only and should not be read as engine or gearbox reliability scores.

About this data

How this page is built and what it can (and can't) say.

These figures come from UK MOT open data for this model year. We surface common failure patterns against similar cars, not a full reliability score, and not a pass/fail verdict on any individual vehicle.

2024 2025

What we include

UK Class 4 cars only. Normal MOT tests (not retests); first test per vehicle per calendar year; results pass, PRS, or fail.

Same-day repairs

PRS means the car failed items that were fixed at the test station and then passed the same day. We count PRS as a first-attempt fail in headline rates so same-day repairs do not hide problems.

How we compare

We compare this model year with other Class 4 cars of similar age and mileage in the same test year. This model family is left out of the peer group so the car is not measured against itself.

What this does not cover

  • MOTs do not cover engine internals, gearboxes, or many electronics; this is not a full reliability score.
  • Common faults come from MOT defect stats, not manufacturer TSBs or recalls.
  • Age and mileage matching reduces, but does not remove, differences in how cars were used and maintained.
  • If the data for a car is too thin to say anything useful, we say so rather than guess.

Contains public sector information licensed under the Open Government Licence v3.0.

Check any vehicle’s MOT history

Full MOT history, mileage records, and reliability insights for any UK vehicle.

Run a free check