Model Reports 4 min read Updated 18 Oct 2026

Nissan Primastar 2006: reliability & common MOT faults

In 2025, 50 in every 100 first MOTs on a 2006 Nissan Primastar were passes. Most common reason for a fail: Handbrake efficiency below minimum (roller test).

Summary

With 808 first tests, there are too few to say whether the 2006 Nissan Primastar differs from the model years either side.

At a glance

How 808 first tests went in 2025.

Passed first time
50 in every 100
Did not pass first time
50 in every 100400 failed first-attempt tests
The typical car
19 yearsabout 151,772 miles
First tests counted
808

What failed most often

  1. Handbrake efficiency below minimum (roller test)25 in every 100 failed tests
  2. Suspension arm ball joint (front)18 in every 100 failed tests
  3. Individual sidelight or tail light (front)13 in every 100 failed tests

How we count this. Data: UK MOT open data, 2025. Only Class 4 cars on their first MOT of the year are counted. A car that fails and is fixed at the test station still counts as a fail in the first-attempt rate. These are raw results, not adjusted for age, mileage, or peer mix. The MOT does not test engine or gearbox internals.

Note:

These are patterns across 2006 Nissan Primastar vehicles in 2025, not a prediction that any one car will have them. Faults are grouped by part of the car. They come from MOT defect codes, not manufacturer bulletins, recalls or a diagnosis of any one car.

Suspension

One fault: suspension arm ball joint (front), 2.7 times as often as on similar cars.

Figures below are measured across the 398 of 400 failed first attempts (99.5%) that recorded an odometer reading in 2025. Mileage is needed to compare like with like.

We only list faults with at least 20 failures and a rate of about 2.0 times that of similar cars, which keeps one-off results out of the list.

Suspension arm ball joint (front)

Failed on 73 first tests2.7 times as often as similar carsPossible evidence

What it means

A suspension arm ball joint is failed under the general suspension pin, bush or joint wording. Excessively worn is Major, and likely to become detached is graded Dangerous.

Also noted as an advisory

Testers also noted it as an advisory, worn but not yet failing, on 25 first tests, 2.0 times as often as on similar cars.

Data: UK MOT open data, 2025. Compared with cars of the same age and mileage. Advisories count notes recorded on failed first tests only.

Lamps and electrical

One fault: individual sidelight or tail light (rear), 2.6 times as often as on similar cars.

Individual sidelight or tail light (rear)

Failed on 35 first tests2.6 times as often as similar carsPossible evidence

What it means

A position lamp showing red light to the front or white light to the rear is Major. Rear lamps must show a steady red light, and front ones can show white, predominantly white with a blue tinge, or yellow if combined in a yellow headlamp. With a multiple light source, up to half not working is Minor and more than half is Major.

Data: UK MOT open data, 2025. Compared with cars of the same age and mileage.

Steering

One fault: track rod end (front), 2.5 times as often as on similar cars.

Track rod end (front)

Failed on 48 first tests2.5 times as often as similar carsPossible evidence

What it means

A steering ball joint with excessive wear or free play is Major, and one worn to the extent there is a serious risk of detachment is graded Dangerous. A dust cover that is damaged but still keeps dirt out is Minor, and one missing or no longer keeping dirt out is Major. Testers must tell wear from a joint's built-in clearance or spring loading.

Data: UK MOT open data, 2025. Compared with cars of the same age and mileage.

Brakes

One fault: handbrake efficiency below minimum (roller test), 2.5 times as often as on similar cars.

Handbrake efficiency below minimum (roller test)

Failed on 98 first tests2.5 times as often as similar carsPossible evidence

What it means

A parking brake with efficiency below the minimum requirement is Major, and graded Dangerous where efficiency is less than half of the required value. On a roller brake tester, the requirement counts as met if more than half of the wheels of a brake system lock. The check applies only to vehicles whose parking brake was not already tested as the secondary brake.

Data: UK MOT open data, 2025. Compared with cars of the same age and mileage.

Seat belts and restraints

One fault: airbag warning light, 2.0 times as often as on similar cars.

Airbag warning light

Failed on 28 first tests2.0 times as often as similar carsPossible evidence

What it means

The airbag warning lamp (SRS MIL in DVSA's wording) is failed only if it indicates a system malfunction, which is Major. A lamp lit to show the passenger airbag is disabled is not to be regarded as a defect. Dashboard messages are not a defect in their own right, though they can help the tester confirm a malfunction.

Data: UK MOT open data, 2025. Compared with cars of the same age and mileage.

Advisories

Other things testers noted as worn or close to failing, more often than on similar cars.

An advisory is a note from the tester about something that has not failed yet. It is an early warning, not a fail. Advisories for the faults above are shown with those faults.

Anti-roll bar linkage ball joints (front)

Noted on 24 first tests2.3 times as often as similar carsElevated evidence

Non-component advisories (front)

Noted on 34 first tests2.3 times as often as similar carsElevated evidence

Data: UK MOT open data, 2025. Counts cover advisories recorded on failed first tests only, compared with cars of the same age and mileage.

MOT pass rates

How first tests ended, and how the pass rates are counted.

Passed first time
50in every 100
Passed on the first test.
Fixed at the station
9in every 100
Failed, then fixed at the test station the same day.
Failed
41in every 100
Did not pass, and were not fixed at the test station.

First-attempt pass 50.5% of 808 first tests (2025): only cars that passed first time count. Official-style pass 58.7%: cars fixed at the test station also count as a pass. The 9 fixed and the 41 not fixed make the 50 in every 100 that did not pass first time.

Same model, other years

Passed first time in every 100, all tested in 2025.

40608010020062010Older carsNewer cars
40608010020062010Newer cars

Newer cars are younger, so look for a jump rather than the climb. A year earlier (2024), when these cars were a year younger, 48 in every 100 passed first time.

YearPassed first timeFirst tests
200343 in every 100352
200447 in every 100560
200546 in every 100755
2006 This car50 in every 100808
200749 in every 1001,033
200847 in every 100711
200947 in every 100608
201047 in every 100369
201148 in every 100788
201250 in every 100446
201340 in every 100441
201451 in every 100390

FAQs

Short answers about how to read this model-year guide.

With 808 first tests, there are too few to say whether the 2006 Nissan Primastar differs from the model years either side. Its main cause of failure was Handbrake efficiency below minimum (roller test), about 25 in every 100 failed tests. In 2025, 50.5% of 808 first MOTs on the 2006 Nissan Primastar passed first time (PRS: items fixed at the station the same day, counted as a fail). The official-style rate including PRS is 58.7%. Among 400 failed first-attempt MOT tests (test year 2025), Suspension arm ball joint (front) appears more often than on similar cars (18.3% of those tests; 73 observed failures; about 2.7× more often than similar cars). There is no single reliability score here; this is a pre-purchase checklist built from DVSA open data, not a guarantee for any individual car.
Ranked by how often they were actually recorded, the items that most often failed a 2006 Nissan Primastar at the first attempt were Handbrake efficiency below minimum (roller test) (24.6%), Suspension arm ball joint (front) (18.3%) and Individual sidelight or tail light (front) (12.6%), each as a share of the year's failed first attempts. That is what goes wrong most often on the car. The common faults table shows a different measure: faults that are unusual compared with similar cars.
Among failed first-attempt tests we highlight patterns that appear more often than on similar cars. Top example: Suspension arm ball joint (front) (18.3% of those tests; 73 observed failures; about 2.7× more often than similar cars). These are statistical signals, not a diagnosis of any individual car.
Suspension arm ball joint (front) shows up more often than on similar cars (18.3% of those tests; 73 observed failures; about 2.7× more often than similar cars). That does not prove a design fault. Age, mileage, and how the car was used still matter. Treat it as a pre-purchase checkpoint, not a manufacturer service bulletin.
Common MOT problem areas for the 2006 Nissan Primastar include Suspension arm ball joint (front), Individual sidelight or tail light (rear), Track rod end (front). These are the faults that stand out compared with similar cars, not a complete list of what can go wrong on any individual car.
Advisories flag issues noted at the test and are not a fail rate. We show advisory patterns that appear more often than on similar cars among failed first-attempt tests, separate from common failure rows. Use them as early-warning checks, not as a pass/fail score.
This page highlights MOT failure patterns for the 2006 Nissan Primastar (registration year) using UK DVSA open data for the selected test year. Patterns are compared with cars of a similar age and mileage. It is a buyer checklist from MOT defect statistics, not a full service history or manufacturer service-bulletin list.
No. MOT tests do not cover engine internals, gearboxes, or many electronic modules. Patterns here come from MOT defect statistics only and should not be read as engine or gearbox reliability scores.

About this data

How this page is built and what it can (and can't) say.

These figures come from UK MOT open data for this model year. We surface common failure patterns against similar cars, not a full reliability score, and not a pass/fail verdict on any individual vehicle.

2024 2025

What we include

UK Class 4 cars only. Normal MOT tests (not retests); first test per vehicle per calendar year; results pass, PRS, or fail.

Same-day repairs

PRS means the car failed items that were fixed at the test station and then passed the same day. We count PRS as a first-attempt fail in headline rates so same-day repairs do not hide problems.

How we compare

We compare this model year with other Class 4 cars of similar age and mileage in the same test year. This model family is left out of the peer group so the car is not measured against itself.

What this does not cover

  • MOTs do not cover engine internals, gearboxes, or many electronics; this is not a full reliability score.
  • Common faults come from MOT defect stats, not manufacturer TSBs or recalls.
  • Age and mileage matching reduces, but does not remove, differences in how cars were used and maintained.
  • If the data for a car is too thin to say anything useful, we say so rather than guess.

Contains public sector information licensed under the Open Government Licence v3.0.

Check any vehicle’s MOT history

Full MOT history, mileage records, and reliability insights for any UK vehicle.

Run a free check