At a glance
How 6,889 first tests went in 2025.
- Passed first time
- 59 in every 100
- Did not pass first time
- 41 in every 1002,815 failed first-attempt tests
- The typical car
- 20 yearsabout 115,722 miles
- First tests counted
- 6,889
What failed most often
- Suspension arm ball joint (front)21 in every 100 failed tests
- Coil spring (front)13 in every 100 failed tests
- Petrol engine warning light10 in every 100 failed tests
How we count this. Data: UK MOT open data, 2025. Only Class 4 cars on their first MOT of the year are counted. A car that fails and is fixed at the test station still counts as a fail in the first-attempt rate. These are raw results, not adjusted for age, mileage, or peer mix. The MOT does not test engine or gearbox internals.
These are patterns across 2005 Mercedes-Benz C-Class vehicles in 2025, not a prediction that any one car will have them. Faults are grouped by part of the car. A wear pattern follows age and use more than the way the car was built. They come from MOT defect codes, not manufacturer bulletins, recalls or a diagnosis of any one car.
Suspension
Four faults. The strongest is the anti-roll bar linkage pins and bushes (rear): 13 times as often as on similar cars.
Figures below are measured across the 2,810 of 2,815 failed first attempts (99.8%) that recorded an odometer reading in 2025. Mileage is needed to compare like with like.
We only list faults with at least 20 failures and a rate of about 2.0 times that of similar cars, which keeps one-off results out of the list.
Anti-roll bar linkage pins and bushes (rear)
What it means
Excessive wear in an anti-roll bar linkage pin or bush is Major. If the pin or bush is likely to become detached, it is graded Dangerous. The wording is DVSA's general one for a suspension pin, bush or joint.
Also noted as an advisory
Testers also noted it as an advisory, worn but not yet failing, on 83 first tests, 12 times as often as on similar cars.
Suspension arm ball joint (front)
What it means
A suspension arm ball joint is failed under the general suspension pin, bush or joint wording. Excessively worn is Major, and likely to become detached is graded Dangerous.
Also noted as an advisory
Testers also noted it as an advisory, worn but not yet failing, on 224 first tests, 3.0 times as often as on similar cars.
Coil spring (front)
What it means
A missing bump stop rubber is not a reason to fail a coil spring. When the vehicle is jacked and lowered, a spring that does not correctly locate as the suspension returns to its normal running position is rejected as insecurely attached. A missing spring is Major, and graded Dangerous where directional control is affected.
Anti-roll bar ball joint dust cover (front)
Data: UK MOT open data, 2025. Compared with cars of the same age and mileage. Advisories count notes recorded on failed first tests only.
Road wheels
One fault: wheel fixings (front), 3.9 times as often as on similar cars.
Wheel fixings (front)
Data: UK MOT open data, 2025. Compared with cars of the same age and mileage.
Tyres
One wear pattern: tyre tread depth (rear), 2.9 times as often as on similar cars.
Tyre tread depth (rear)
What it means
Only primary grooves count when tread depth is assessed: those holding the wear indicators, or cut as deep as those when new. Shallower secondary grooves are ignored. Tread depth below the minimum for the vehicle is Dangerous, and so is a pattern not visible over the whole tread, but that second row applies only to vehicles that need the lower minimum.
Data: UK MOT open data, 2025. Compared with cars of the same age and mileage.
Lamps and electrical
One fault: side repeater indicators, 2.0 times as often as on similar cars.
Side repeater indicators
What it means
Sequential or dynamic direction indicators are not a reason to fail. Where a side repeater is required, it is allowed to be part of the front direction indicator if it has a marked wraparound lens, or an amber light coming through the front lens when viewed from a set distance to the side of the rear bumper. A lens defect with no effect on the emitted light is Minor, and one that adversely affects the light is Major.
Data: UK MOT open data, 2025. Compared with cars of the same age and mileage.
Advisories
Other things testers noted as worn or close to failing, more often than on similar cars.
An advisory is a note from the tester about something that has not failed yet. It is an early warning, not a fail. Advisories for the faults above are shown with those faults.
Anti-roll bar (rear)
Wheel bearings (front)
Anti-roll bar pins and bushes (rear)
Structural sub-frame condition (rear)
Flexible brake hoses (rear)
Individual direction indicators (rear)
Data: UK MOT open data, 2025. Counts cover advisories recorded on failed first tests only, compared with cars of the same age and mileage.
MOT pass rates
How first tests ended, and how the pass rates are counted.
- Passed first time
- 59in every 100
- Passed on the first test.
- Fixed at the station
- 7in every 100
- Failed, then fixed at the test station the same day.
- Failed
- 34in every 100
- Did not pass, and were not fixed at the test station.
First-attempt pass 59.1% of 6,889 first tests (2025): only cars that passed first time count. Official-style pass 66.3%: cars fixed at the test station also count as a pass. The 7 fixed and the 34 not fixed make the 41 in every 100 that did not pass first time.
Petrol and diesel
Figures are in every 100 first tests. Cars with more miles usually fail more often, so the same-mileage figure gives every fuel the mileage mix of all the cars in this year.
Same model, other years
Passed first time in every 100, all tested in 2025.
Newer cars are younger, so look for a jump rather than the climb. A year earlier (2024), when these cars were a year younger, 57 in every 100 passed first time.
| Year | Passed first time | First tests |
|---|---|---|
| 1996 | 72 in every 100 | 347 |
| 1997 | 68 in every 100 | 584 |
| 1998 | 71 in every 100 | 723 |
| 1999 | 68 in every 100 | 644 |
| 2000 | 66 in every 100 | 501 |
| 2001 | 64 in every 100 | 1,041 |
| 2002 | 63 in every 100 | 1,935 |
| 2003 | 58 in every 100 | 3,438 |
| 2004 | 58 in every 100 | 5,099 |
| 2005 This car | 59 in every 100 | 6,889 |
| 2006 | 58 in every 100 | 8,303 |
| 2007 | 61 in every 100 | 10,849 |
| 2008 | 63 in every 100 | 12,485 |
| 2009 | 64 in every 100 | 11,974 |
| 2010 | 66 in every 100 | 12,159 |
| 2011 | 67 in every 100 | 17,849 |
| 2012 | 67 in every 100 | 24,448 |
| 2013 | 69 in every 100 | 22,380 |
| 2014 | 75 in every 100 | 24,165 |
| 2015 | 78 in every 100 | 32,615 |
| 2016 | 80 in every 100 | 34,859 |
| 2017 | 81 in every 100 | 37,580 |
| 2018 | 84 in every 100 | 26,966 |
| 2019 | 85 in every 100 | 23,530 |
| 2020 | 86 in every 100 | 9,433 |
| 2021 | 87 in every 100 | 5,769 |
| 2022 | 89 in every 100 | 4,378 |
If you are buying one
What this year's MOT record means for the decision in front of you.
Mileage matters most on a 2005 C-Class.
Of 2005 C-Class vehicles with under 81,000 miles, 69 in every 100 passed their 2025 MOT first time. With 155,000 miles or more, 54 in every 100 did.
What to check at your mileage
How often each fault turned up on a failed first test, by the car's mileage. Read it as: what is likely to need looking at on a car like the one in front of you.
| Under 81,000 | 105,000–127,000 | 155,000 and over | |
|---|---|---|---|
| Suspension arm ball joint (front) | 5.3 | 10.4 | 9.2 |
| Coil spring (front) | 3.9 | 4.1 | 6.5 |
| Petrol engine warning light | 3.4 | 4.9 | 3.8 |
| Headlight aim | 2.5 | 4.3 | 4.3 |
| Handbrake efficiency below minimum (roller test) | 1.2 | 2.3 | 5.7 |
Faults per 100 first tests, by the car's mileage at the test.
When a car fails
of failed cars had one item to fix.
of failed cars had three or more items to fix.
of all first tests had a defect the tester marked dangerous (unsafe to drive away).
Every figure here is a first-attempt MOT rate from DVSA open data for this model line, for cars of this model year tested in 2025. Each mileage band holds a fifth of the tests. MOTs do not test engine or gearbox internals, so this is a pre-purchase checklist, not a full reliability score.
FAQs
Short answers about how to read this model-year guide.
About this data
How this page is built and what it can (and can't) say.
These figures come from UK MOT open data for this model year. We surface common failure patterns against similar cars, not a full reliability score, and not a pass/fail verdict on any individual vehicle.
What we include
UK Class 4 cars only. Normal MOT tests (not retests); first test per vehicle per calendar year; results pass, PRS, or fail.
Same-day repairs
PRS means the car failed items that were fixed at the test station and then passed the same day. We count PRS as a first-attempt fail in headline rates so same-day repairs do not hide problems.
How we compare
We compare this model year with other Class 4 cars of similar age and mileage in the same test year. This model family is left out of the peer group so the car is not measured against itself.
What this does not cover
- MOTs do not cover engine internals, gearboxes, or many electronics; this is not a full reliability score.
- Common faults come from MOT defect stats, not manufacturer TSBs or recalls.
- Age and mileage matching reduces, but does not remove, differences in how cars were used and maintained.
- If the data for a car is too thin to say anything useful, we say so rather than guess.
Contains public sector information licensed under the Open Government Licence v3.0.
Check any vehicle’s MOT history
Full MOT history, mileage records, and reliability insights for any UK vehicle.
Run a free check