At a glance
How 817 first tests went in 2025.
- Passed first time
- 69 in every 100
- Did not pass first time
- 31 in every 100257 failed first-attempt tests
- The typical car
- 4 yearsabout 31,928 miles
- First tests counted
- 817
How we count this. Data: UK MOT open data, 2025. Only Class 4 cars on their first MOT of the year are counted. A car that fails and is fixed at the test station still counts as a fail in the first-attempt rate. These are raw results, not adjusted for age, mileage, or peer mix. The MOT does not test engine or gearbox internals.
These are patterns across 2021 Maxus E Deliver 3 vehicles in 2025, not a prediction that any one car will have them. Faults are grouped by part of the car. A wear pattern follows age and use more than the way the car was built. They come from MOT defect codes, not manufacturer bulletins, recalls or a diagnosis of any one car.
Steering
One fault: track rod end (front), 15 times as often as on similar cars.
Figures below are measured across the 257 failed first attempts in 2025 that had a mileage recorded, which allows a like-for-like comparison.
We only list faults with at least 20 failures and a rate of about 2.0 times that of similar cars, which keeps one-off results out of the list.
Track rod end (front)
What it means
A steering ball joint with excessive wear or free play is Major, and one worn to the extent there is a serious risk of detachment is graded Dangerous. A dust cover that is damaged but still keeps dirt out is Minor, and one missing or no longer keeping dirt out is Major. Testers must tell wear from a joint's built-in clearance or spring loading.
Data: UK MOT open data, 2025. Compared with cars of the same age and mileage.
Brakes
One fault: handbrake efficiency below minimum (roller test), 10 times as often as on similar cars.
Handbrake efficiency below minimum (roller test)
What it means
A parking brake with efficiency below the minimum requirement is Major, and graded Dangerous where efficiency is less than half of the required value. On a roller brake tester, the requirement counts as met if more than half of the wheels of a brake system lock. The check applies only to vehicles whose parking brake was not already tested as the secondary brake.
Data: UK MOT open data, 2025. Compared with cars of the same age and mileage.
Lamps and electrical
Two faults. The strongest is the brake light (rear): 10 times as often as on similar cars.
Brake light (rear)
What it means
All stop lamps missing or not working is graded Dangerous, and so is a stop lamp that stays on when the brakes are released. A stop lamp that is missing or not working is Major. On some vehicles with LED rear lamps, part of the stop lamp can go out when the rear fog lamp is lit, which is not regarded as a defect.
Headlight
What it means
On vehicles first used on or after a set date, a halogen headlamp unit converted to take HID or LED bulbs fails for light source and lamp not compatible, which is Major. A complete unit built with those light sources is not failed for that. The precise position of the lamps is not part of the inspection beyond a visual look to see that they sit at about the same height and distance from each side.
Data: UK MOT open data, 2025. Compared with cars of the same age and mileage.
Suspension
One fault: suspension arm pins and bushes (front), 8.8 times as often as on similar cars.
Suspension arm pins and bushes (front)
What it means
Pins and bushes on suspension arms fail as Major when they are excessively worn. They are graded Dangerous when likely to become detached. DVSA uses the same wording for a suspension joint.
Data: UK MOT open data, 2025. Compared with cars of the same age and mileage.
Tyres
One wear pattern: tyre pressure monitoring system, 4.1 times as often as on similar cars.
Tyre pressure monitoring system
What it means
A tyre pressure monitoring system that is obviously inoperative is graded Major, and so is one listed as malfunctioning or obviously inoperative. The Minor row uses the word malfunctioning too, but its detail is a warning lamp indicating a fault, and it also covers a tyre that is obviously under-inflated.
Data: UK MOT open data, 2025. Compared with cars of the same age and mileage.
MOT pass rates
How first tests ended, and how the pass rates are counted.
- Passed first time
- 69in every 100
- Passed on the first test.
- Fixed at the station
- 7in every 100
- Failed, then fixed at the test station the same day.
- Failed
- 24in every 100
- Did not pass, and were not fixed at the test station.
First-attempt pass 68.5% of 817 first tests (2025): only cars that passed first time count. Official-style pass 76.4%: cars fixed at the test station also count as a pass. The 7 fixed and the 24 not fixed make the 31 in every 100 that did not pass first time.
Same model, other years
Passed first time in every 100, all tested in 2025.
| Year | Passed first time | First tests |
|---|---|---|
| 2021 This car | 69 in every 100 | 817 |
| 2022 | 73 in every 100 | 740 |
Newer cars are younger, so look for a jump rather than the climb.
FAQs
Short answers about how to read this model-year guide.
About this data
How this page is built and what it can (and can't) say.
These figures come from UK MOT open data for this model year. We surface common failure patterns against similar cars, not a full reliability score, and not a pass/fail verdict on any individual vehicle.
What we include
UK Class 4 cars only. Normal MOT tests (not retests); first test per vehicle per calendar year; results pass, PRS, or fail.
Same-day repairs
PRS means the car failed items that were fixed at the test station and then passed the same day. We count PRS as a first-attempt fail in headline rates so same-day repairs do not hide problems.
How we compare
We compare this model year with other Class 4 cars of similar age and mileage in the same test year. This model family is left out of the peer group so the car is not measured against itself.
What this does not cover
- MOTs do not cover engine internals, gearboxes, or many electronics; this is not a full reliability score.
- Common faults come from MOT defect stats, not manufacturer TSBs or recalls.
- Age and mileage matching reduces, but does not remove, differences in how cars were used and maintained.
- If the data for a car is too thin to say anything useful, we say so rather than guess.
Contains public sector information licensed under the Open Government Licence v3.0.
Check any vehicle’s MOT history
Full MOT history, mileage records, and reliability insights for any UK vehicle.
Run a free check