Model Reports 8 min read Updated 11 Sep 2026 DVSA open data · 9,733 tests analysed

Kia Picanto 2011: reliability & common MOT faults

4,211 first-attempt MOT failures were recorded on the 2011 Kia Picanto in 2025. Figures are among first-attempt failed MOT tests, not among all tests.

Rbt (sp) was the most common reason a 2011 Picanto failed its MOT — 21.4% of its failed first attempts.

First-attempt pass

56.7%

of 9,733 first tests (2025)

First tests

9,733

test year 2025

Failed first attempts

4,211

failed first-attempt tests

MOT pass rates

First-attempt and official-style rates among class 4 first tests of the year.

First-attempt pass

56.7%

of 9,733 first tests (2025)

Official-style pass

64.3%

incl. same-day PRS fixes

First tests

9,733

class 4 · first MOT of the year

Typical age 14.0 yrs · median mileage 66,170 mi

vs 2024: +1.0 pp first-attempt

Note:

  • Class 4 cars · first MOT of the year per vehicle · P/PRS/F outcomes (2025 data).
  • PRS (fixed at the station the same day) counts as a fail in the first-attempt rate.
  • Raw outcomes for this cohort — not adjusted for age, mileage, or peer mix.
  • MOT doesn't test engine or gearbox internals.

Common faults

Failure patterns that show up more often on this registration year than on similar cars.

These MOT failure patterns show up more often on this registration year than on similar cars of the same class, age, and mileage.

Shares below are measured across the 4,202 of 4,211 failed first attempts (99.8%) that recorded an odometer reading in 2025 — the subset the age-and-mileage comparison can be computed on.

Standout: Seat belts — Condition (front) — 3.6% of this year's failed first attempts

Recorded on 153 of those tests. It tops the table on elevation — about 16× more often than on similar cars of the same age and mileage. That is what makes it unusual for its class, which is a different question from what is most likely to fail; the buying checklist ranks by that. The full ranked list is in the table below.

Fault pattern Location Failures vs similar cars Share of fails Confidence
Seat belts — Condition (front)
Seat belts and supplementary restraint systems > Seat belts > Condition
 Front 153 ×16 3.6% Strong
Parking brake performance (rear)
Brakes > Brake performance > Parking brake performance > Rbt > Parking brake performance
 Rear 176 ×5.6 4.2% Strong
Rbt (sp)
Brakes > Brake performance > Parking brake efficiency (sp) > Rbt (sp)
 Any 898 ×5.4 21.4% Strong
Rigid brake pipes (rear)
Brakes > Rigid brake pipes
 Rear 197 ×3.0 4.7% Possible
Catalyst emissions
Noise, emissions and leaks > Exhaust emissions > Spark ignition > Catalyst emissions
 Any 354 ×2.8 8.4% Possible
Rigid brake pipes (front)
Brakes > Rigid brake pipes
 Front 91 ×2.4 2.2% Possible
Ball joint dust cover (front)
Suspension > Suspension arms > Ball joint dust cover
 Front 160 ×2.3 3.8% Possible
Emissions not tested
Noise, emissions and leaks > Exhaust emissions > Spark ignition > Emissions not tested
 Any 114 ×2.3 2.7% Possible

Only patterns that clear minimum sample and elevation thresholds are shown (at least 20 failures and about 2.0× more often than similar cars).

Note: Rates and comparisons are among first-attempt failed tests, not all MOTs. Patterns come from MOT defect codes — not manufacturer service bulletins, recalls, or a diagnosis of any individual car. Failures and advisories are listed separately.

Wear patterns

Usage and mileage effects that often track road use rather than model design.

These patterns look like wear or usage effects rather than model-specific design faults. Tyres, brake friction material, and alignment-related defects often track mileage and road use.

Pattern Location Failures vs similar cars Share of fails Confidence
Brake discs (rear)
Brakes > Mechanical brake components > Brake discs and drums > Brake discs
 Rear 95 ×2.2 2.3% Wear
Note: These patterns are not treated as a model design fault in our common-faults ranking.

Advisories

Notes recorded at the test that appear more often than on similar cars.

Advisory notes recorded on failed first-attempt tests that appear more often than on similar cars.

Advisory pattern Location Notes vs similar cars Share Confidence
Seat belts — Condition (front)
Seat belts and supplementary restraint systems > Seat belts > Condition
 Front 242 ×9.6 5.8% Strong
Side repeaters
Lamps, reflectors and electrical equipment > Direction indicators > Flashing type > Side repeaters
 Any 35 ×4.7 0.8% Elevated
Parking brake efficiency (Trikes, quads and pre-68 vehicles)
Brakes > Brake performance > Parking brake performance > Rbt > Parking brake efficiency (Trikes, quads and pre-68 vehicles)
 Any 21 ×3.9 0.5% Elevated
Service brake performance (front)
Brakes > Brake performance > Service brake performance > Plate brake tester > Service brake performance
 Front 41 ×3.8 1.0% Possible
Rigid brake pipes (rear)
Brakes > Rigid brake pipes
 Rear 552 ×3.4 13.1% Possible
Exhaust system (front)
Body, chassis, structure > Exhaust system
 Front 205 ×2.8 4.9% Elevated
Service brake performance (rear)
Brakes > Brake performance > Service brake performance > Rbt > Service brake performance
 Rear 207 ×2.1 4.9% Elevated
Service brake performance (front)
Brakes > Brake performance > Service brake performance > Rbt > Service brake performance
 Front 152 ×2.0 3.6% Elevated
Note: Advisories are not a fail rate — they flag issues noted at the test, often before they become failures.

If you are buying one

What this year's MOT record means for the decision in front of you.

Nothing separates this year from the Picantos either side of it, so buy on the individual car. The checks below are the items that actually failed 2011 Picantos, commonest first.

Other Picanto years worth knowing about

Newer cars always pass more often, so a plain "best year" list would just rank by age. These are the years that beat or miss the trend their own neighbouring years set — the only age-adjusted signal this data supports.

Year vs the years either side First-attempt pass (rises with newer cars) First tests
2015 Picanto +1.6 pp better 73.7% 13,160

What to check on a 2011 Picanto

The items that failed 2011 Picantos most often, as a share of the year's failed first attempts. This is what goes wrong, not what is unusual — the table further up the page covers that.

  • Rbt (sp) — recorded on 21.4% of failed first attempts
  • Position lamp (front) — recorded on 17.2% of failed first attempts
  • Catalyst emissions — recorded on 8.4% of failed first attempts
  • Drive shafts — Joints (front) — recorded on 7.2% of failed first attempts
  • Tyres — Condition (front) — recorded on 6.7% of failed first attempts

Every figure here is a first-attempt MOT rate from DVSA open data for this model line. MOTs do not test engine or gearbox internals, so this is a pre-purchase checklist, not a full reliability score.

FAQs

Short answers about how to read this model-year guide.

Rbt (sp) was the most common reason a 2011 Picanto failed its MOT — 21.4% of its failed first attempts. In 2025, 56.7% of 9,733 first MOTs on the 2011 Kia Picanto passed first time (PRS — items fixed at the station the same day — counted as a fail). The official-style rate including PRS is 64.3%. Among 4,211 failed first-attempt MOT tests (test year 2025), Seat belts — Condition (front) appears more often than on si…
Ranked by how often they were actually recorded, the items that failed 2011 Kia Picantos most often at the first attempt were Rbt (sp) (21.4%), Position lamp (front) (17.2%) and Catalyst emissions (8.4%) — each as a share of the year's failed first attempts. That is what goes wrong on the car. It is a different question from which patterns are unusual for the class, which the common-faults table answers.
Among failed first-attempt tests we highlight patterns that appear more often than on similar cars. Top example: Seat belts — Condition (front) (3.6% of those tests; 153 observed failures; about 16× more often than similar cars). These are statistical signals, not a diagnosis of any individual car.
Seat belts — Condition (front) shows up more often than on similar cars (3.6% of those tests; 153 observed failures; about 16× more often than similar cars). That does not prove a design fault — age, mileage, and how the car was used still matter. Treat it as a pre-purchase check point, not a manufacturer service bulletin.
Common MOT problem areas for the 2011 Kia Picanto include Seat belts — Condition (front), Parking brake performance (rear), Rbt (sp). These patterns show up more often than on similar cars after we filter out sparse noise — not a full list of every possible fault on an individual car.
Advisories flag issues noted at the test and are not a fail rate. We show advisory patterns that appear more often than on similar cars among failed first-attempt tests, separate from common failure rows. Use them as early-warning checks, not as a pass/fail score.
This page highlights MOT failure patterns for the 2011 Kia Picanto (registration year) using UK DVSA open data for the selected test year. Patterns are compared with cars of a similar age and mileage. It is a buyer checklist from MOT defect statistics — not a full service history or manufacturer service-bulletin list.
No. MOT tests do not cover engine internals, gearboxes, or many electronic modules. Patterns here come from MOT defect statistics only and should not be read as engine or gearbox reliability scores.

About this data

How this page is built and what it can (and can't) say.

These figures come from UK MOT open data for this model year. We surface common failure patterns against similar cars — not a full reliability score, and not a pass/fail verdict on any individual vehicle.

2024 2025

What we include

UK Class 4 cars only. Normal MOT tests (not retests); first test per vehicle per calendar year; results pass, PRS, or fail.

Same-day repairs

PRS means the car failed items that were fixed at the test station and then passed the same day. We count PRS as a first-attempt fail in headline rates so same-day repairs do not hide problems.

How we compare

We compare this model year with other Class 4 cars of similar age and mileage in the same test year. This model family is left out of the peer group so the car is not measured against itself.

What this does not cover

  • MOTs do not cover engine internals, gearboxes, or many electronics — this is not a full reliability score.
  • Common faults come from MOT defect stats, not manufacturer TSBs or recalls.
  • Age and mileage matching reduces — but does not remove — differences in how cars were used and maintained.
  • We never invent pass rates, star scores, or ranks when those data marts are missing.

Contains public sector information licensed under the Open Government Licence v3.0.

Check any vehicle’s MOT history

Full MOT history, mileage records, and reliability insights for any UK vehicle.

Run a free check