Model Reports 8 min read Updated 11 Sep 2026 DVSA open data · 4,249 tests analysed

Isuzu D-Max 2015: reliability & common MOT faults

1,503 first-attempt MOT failures were recorded on the 2015 Isuzu D-Max in 2025. Figures are among first-attempt failed MOT tests, not among all tests.

Rear fog lamp was the most common reason a 2015 D-Max failed its MOT — 13.0% of its failed first attempts.

First-attempt pass

64.6%

of 4,249 first tests (2025)

First tests

4,249

test year 2025

Failed first attempts

1,503

failed first-attempt tests

MOT pass rates

First-attempt and official-style rates among class 4 first tests of the year.

First-attempt pass

64.6%

of 4,249 first tests (2025)

Official-style pass

70.0%

incl. same-day PRS fixes

First tests

4,249

class 4 · first MOT of the year

Typical age 10.0 yrs · median mileage 94,387 mi

vs 2024: -2.9 pp first-attempt

Note:

  • Class 4 cars · first MOT of the year per vehicle · P/PRS/F outcomes (2025 data).
  • PRS (fixed at the station the same day) counts as a fail in the first-attempt rate.
  • Raw outcomes for this cohort — not adjusted for age, mileage, or peer mix.
  • MOT doesn't test engine or gearbox internals.

Common faults

Failure patterns that show up more often on this registration year than on similar cars.

These MOT failure patterns show up more often on this registration year than on similar cars of the same class, age, and mileage.

Shares below are measured across the 1,501 of 1,503 failed first attempts (99.9%) that recorded an odometer reading in 2025 — the subset the age-and-mileage comparison can be computed on.

Standout: Rear fog lamp (rear) — 13.0% of this year's failed first attempts

Recorded on 195 of those tests. It tops the table on elevation — about 12× more often than on similar cars of the same age and mileage. On this year it is also the commonest failure, so it answers both questions at once. The full ranked list is in the table below.

Fault pattern Location Failures vs similar cars Share of fails Confidence
Pins and bushes (front)
Suspension > Anti-roll bars > Pins and bushes
 Front 60 ×19 4.0% Likely
Rear fog lamp (rear)
Lamps, reflectors and electrical equipment > Front and rear fog lamps > Rear fog lamp > Rear fog lamp
 Rear 195 ×12 13.0% Strong
Wheel bearings (front)
Suspension > Wheel bearings
 Front 112 ×8.3 7.5% Strong
Rigid brake pipes (front)
Brakes > Rigid brake pipes
 Front 67 ×8.1 4.5% Likely
Emissions not tested
Noise, emissions and leaks > Exhaust emissions > Compression ignition > Emissions not tested
 Any 52 ×8.0 3.5% Likely
Rigid brake pipes (rear)
Brakes > Rigid brake pipes
 Rear 78 ×6.6 5.2% Likely
Reversing lamps
Lamps, reflectors and electrical equipment > Reversing lamps > Reversing lamps
 Any 39 ×6.2 2.6% Likely
Exhaust system (rear)
Body, chassis, structure > Exhaust system
 Rear 103 ×5.1 6.9% Strong
Shock absorbers (rear)
Suspension > Shock absorbers
 Rear 156 ×4.7 10.4% Likely
Anti-lock braking system
Brakes > ABS / EBS / ESC > Anti-lock braking system
 Any 86 ×4.3 5.7% Likely

Only patterns that clear minimum sample and elevation thresholds are shown (at least 20 failures and about 2.0× more often than similar cars).

Note: Rates and comparisons are among first-attempt failed tests, not all MOTs. Patterns come from MOT defect codes — not manufacturer service bulletins, recalls, or a diagnosis of any individual car. Failures and advisories are listed separately.

Advisories

Notes recorded at the test that appear more often than on similar cars.

Advisory notes recorded on failed first-attempt tests that appear more often than on similar cars.

Advisory pattern Location Notes vs similar cars Share Confidence
Shackle pins and bushes (rear)
Suspension > Springs > Leaf springs > Shackle pins and bushes
 Rear 23 ×48 1.5% Elevated
Wheel bearings (front)
Suspension > Wheel bearings
 Front 337 ×37 22.5% Strong
Pins and bushes (front)
Suspension > Anti-roll bars > Pins and bushes
 Front 81 ×19 5.4% Likely
Chassis condition (rear)
Body, chassis, structure > Chassis > Chassis condition
 Rear 24 ×12 1.6% Elevated
Flexible brake hoses (front)
Brakes > Flexible brake hoses
 Front 38 ×11 2.5% Elevated
Rigid brake pipes (front)
Brakes > Rigid brake pipes
 Front 169 ×6.8 11.3% Likely
Rigid brake pipes (rear)
Brakes > Rigid brake pipes
 Rear 200 ×6.2 13.3% Likely
Suspension arm (front)
Suspension > Suspension arms > Suspension arm
 Front 29 ×4.4 1.9% Elevated
Note: Advisories are not a fail rate — they flag issues noted at the test, often before they become failures.

If you are buying one

What this year's MOT record means for the decision in front of you.

Nothing separates this year from the D-Max either side of it, so buy on the individual car. The checks below are the items that actually failed 2015 D-Max, commonest first.

What to check on a 2015 D-Max

The items that failed 2015 D-Max most often, as a share of the year's failed first attempts. This is what goes wrong, not what is unusual — the table further up the page covers that.

  • Rear fog lamp — recorded on 13.0% of failed first attempts
  • Position lamp (front) — recorded on 11.6% of failed first attempts
  • Shock absorbers (rear) — recorded on 10.4% of failed first attempts
  • Ball joint (front) — recorded on 10.1% of failed first attempts
  • Rbt (sp) — recorded on 7.6% of failed first attempts

Every figure here is a first-attempt MOT rate from DVSA open data for this model line. MOTs do not test engine or gearbox internals, so this is a pre-purchase checklist, not a full reliability score.

FAQs

Short answers about how to read this model-year guide.

Rear fog lamp was the most common reason a 2015 D-Max failed its MOT — 13.0% of its failed first attempts. In 2025, 64.6% of 4,249 first MOTs on the 2015 Isuzu D-Max passed first time (PRS — items fixed at the station the same day — counted as a fail). The official-style rate including PRS is 70.0%. Among 1,503 failed first-attempt MOT tests (test year 2025), Rear fog lamp (rear) appears more often than on similar c…
Ranked by how often they were actually recorded, the items that failed 2015 Isuzu D-Maxs most often at the first attempt were Rear fog lamp (13.0%), Position lamp (front) (11.6%) and Shock absorbers (rear) (10.4%) — each as a share of the year's failed first attempts. That is what goes wrong on the car. It is a different question from which patterns are unusual for the class, which the common-faults table answers.
Among failed first-attempt tests we highlight patterns that appear more often than on similar cars. Top example: Rear fog lamp (rear) (13.0% of those tests; 195 observed failures; about 12× more often than similar cars). These are statistical signals, not a diagnosis of any individual car.
Rear fog lamp (rear) shows up more often than on similar cars (13.0% of those tests; 195 observed failures; about 12× more often than similar cars). That does not prove a design fault — age, mileage, and how the car was used still matter. Treat it as a pre-purchase check point, not a manufacturer service bulletin.
Common MOT problem areas for the 2015 Isuzu D-Max include Rear fog lamp (rear), Wheel bearings (front), Exhaust system (rear). These patterns show up more often than on similar cars after we filter out sparse noise — not a full list of every possible fault on an individual car.
Advisories flag issues noted at the test and are not a fail rate. We show advisory patterns that appear more often than on similar cars among failed first-attempt tests, separate from common failure rows. Use them as early-warning checks, not as a pass/fail score.
This page highlights MOT failure patterns for the 2015 Isuzu D-Max (registration year) using UK DVSA open data for the selected test year. Patterns are compared with cars of a similar age and mileage. It is a buyer checklist from MOT defect statistics — not a full service history or manufacturer service-bulletin list.
No. MOT tests do not cover engine internals, gearboxes, or many electronic modules. Patterns here come from MOT defect statistics only and should not be read as engine or gearbox reliability scores.

About this data

How this page is built and what it can (and can't) say.

These figures come from UK MOT open data for this model year. We surface common failure patterns against similar cars — not a full reliability score, and not a pass/fail verdict on any individual vehicle.

2024 2025

What we include

UK Class 4 cars only. Normal MOT tests (not retests); first test per vehicle per calendar year; results pass, PRS, or fail.

Same-day repairs

PRS means the car failed items that were fixed at the test station and then passed the same day. We count PRS as a first-attempt fail in headline rates so same-day repairs do not hide problems.

How we compare

We compare this model year with other Class 4 cars of similar age and mileage in the same test year. This model family is left out of the peer group so the car is not measured against itself.

What this does not cover

  • MOTs do not cover engine internals, gearboxes, or many electronics — this is not a full reliability score.
  • Common faults come from MOT defect stats, not manufacturer TSBs or recalls.
  • Age and mileage matching reduces — but does not remove — differences in how cars were used and maintained.
  • We never invent pass rates, star scores, or ranks when those data marts are missing.

Contains public sector information licensed under the Open Government Licence v3.0.

Check any vehicle’s MOT history

Full MOT history, mileage records, and reliability insights for any UK vehicle.

Run a free check