Toyota2009–2013

Auris 1.33 VVTi: Common faults & known problems

Common faults & known problems

6 known faults documented in workshop bulletins. Of these, three concern the brakes and two the steering. Symptoms, causes, repair steps and part numbers are shown where supplied.

Brakes

3 documented faults — symptoms, causes and workshop fixes.

Handbrake lever difficult to operate when driver's seat in fully forward position

Overview

Affects
All models built in UK and Turkey, →07/07.

Cause

Incorrect adjustment of handbrake mechanism.

Repair

  1. Adjust handbrake mechanism to obtain 3-6 notches at handbrake lever whilst applying 200 N.
  2. Carry out brake bedding-in procedure: Drive vehicle at 25 mph (40 kph). Apply handbrake lever 1 notch. Drive vehicle for 400 metres. Release handbrake lever. Wait 5 minutes. Repeat above procedure twice.

Data: Motorwise Workshop. Bulletin 1.

Handbrake lever difficult to operate when driver's seat in fully forward position

Overview

Affects
All models built in Japan, →11/07.
Remedy
Fit modified part

Cause

Incorrect adjustment of handbrake mechanism.

Poor manufacture of handbrake cables.

Repair steps

  1. Fit modified handbrake lever assembly and handbrake cables.
  2. Adjust handbrake mechanism to obtain 3-6 notches at handbrake lever whilst applying 200 N.
  3. Carry out brake bedding-in procedure: Drive vehicle at 25 mph (40 kph). Apply handbrake lever 1 notch. Drive vehicle for 400 metres. Release handbrake lever. Wait 5 minutes. Repeat above procedure twice.

Parts

Parts listed in the bulletin
PartPart numberQty
Handbrake cable46420-127201
Handbrake cable46430-126101
Clamp46402-120301
Handbrake lever assembly46201-12352-**1

Data: Motorwise Workshop. Bulletin 2.

Strong odour from rear brakes

Affects All models, →03/09.Fit modified part

Symptoms

Excessive fuel consumption. Noise from rear brakes.

Cause

Rear brake pads seize in brake caliper carrier due to corrosion and dirt ingress.

Repair

  1. Fit modified rear brake pads.

Data: Motorwise Workshop. Bulletin 4.

Steering

2 documented faults — symptoms, causes and workshop fixes.

Rattling noise from steering column at low speeds over uneven surfaces

Affects All models, →2008.Fit modified part

Cause

Excessive free play in EPS motor drive gears.

Repair

  1. Fit modified steering column.

Data: Motorwise Workshop. Bulletin 3.

Increased engine noise in passenger compartment

Steering column sealing boot cracked/damaged. Fix: fit a new part.

Overview

Affects
All LHD models.
Remedy
Fit new part

Symptoms

Driver's footwell carpet wet after heavy rain. Steering operation not smooth when manoeuvring or parking.

Repair steps

  1. Remove steering column sealing boot and discard.
  2. Fit protective cover to new steering column sealing boot Secure protective cover with retaining strap, ensure a clearance of 0.5 - 1.5 mm.
  3. Fit new steering column sealing boot complete with protective cover.

Parts

Parts listed in the bulletin
PartPart numberQty
Protective cover45254-020201
Steering column sealing bootRefer to manufacturer1

Data: Motorwise Workshop. Bulletin 6.

Body & trim

1 documented fault — symptoms, causes and workshop fixes.

Water ingress into load area

Affects All models, →02/10.

Symptoms

Load area carpet wet.

Cause

Damaged or incorrectly fitted air ventilation outlet grilles, located behind rear bumper.

Repair

  1. Check fitment and condition of air ventilation outlet grilles, replace if necessary.
Parts1 part
Parts listed in the bulletin
PartPart numberQty
Air ventilation outlet grille62940-020112

Data: Motorwise Workshop. Bulletin 5.

Glossary

Technical terms used in this guide.

LHD
Left-hand drive — steering wheel on the left
Caliper
The part that squeezes the brake pads onto the disc

Frequently asked questions

What are the common faults with the Toyota Auris 1.33 VVTi?

This guide contains six workshop bulletins for the Toyota Auris 1.33 VVTi. Of these, three concern the brakes and two the steering. Symptoms, causes, repair steps and part numbers are shown where supplied.

Does every Toyota Auris 1.33 VVTi have these faults?

No. These are patterns documented across the model by workshops, not predictions for an individual vehicle. Where a fault applies only to certain vehicles or VIN ranges, that is listed with the fault.

Can I check for Toyota Auris 1.33 VVTi faults myself?

Many of them. The documented symptoms can be seen, heard or felt during a test drive.

Related guides

Glossary term

See in the glossary →